Introduction
This manual provides essential information for the installation, maintenance, and care of your Moen 52613 Commercial Laminar Flow Aerator. This aerator is designed as a replacement commercial service kit, ensuring optimal performance and longevity for your faucet.
Safety Information
Important: Always turn off the main water supply before attempting any installation, removal, or maintenance on your faucet or plumbing system. Open the faucet handle to relieve any residual water pressure and confirm that the water supply is completely shut off.
Failure to follow these safety precautions can result in water damage or personal injury.
Package Contents
- Moen 52613 Commercial Laminar Flow Aerator (1)
Image: The Moen 52613 Commercial Laminar Flow Aerator, a cylindrical chrome component with a perforated screen at one end.
Installation Instructions
- Turn Off Water Supply: Locate the main water shut-off valve for your faucet (usually under the sink) and turn it off completely.
- Relieve Pressure: Open the faucet handle to drain any remaining water and relieve pressure in the lines.
- Remove Old Aerator: Carefully unscrew the existing aerator from the faucet spout. You may need an aerator key or pliers wrapped in a cloth to avoid scratching the finish.
- Clean Faucet Spout: Clean any debris or mineral buildup from the threads inside the faucet spout.
- Install New Aerator: Thread the Moen 52613 Commercial Laminar Flow Aerator onto the faucet spout. Hand-tighten first, then use an aerator key or pliers (with cloth) to gently tighten until snug. Do not overtighten.
- Restore Water Supply: Slowly turn the main water supply back on.
- Check for Leaks: Turn on the faucet and check for any leaks around the newly installed aerator. If leaks occur, gently tighten the aerator further.
Image: A faucet with the laminar flow aerator installed, showing a clear, non-aerated stream of water flowing into a sink.
Operating Instructions
The Moen 52613 Commercial Laminar Flow Aerator provides a clear, non-aerated stream of water. Simply operate your faucet as usual to achieve the desired water flow. This aerator is designed to deliver a maximum flow rate of 1 gallon per minute (GPM).
Maintenance and Care
To maintain the finish and performance of your Moen aerator and faucet:
- Cleaning: Use a soft, damp cloth and mild soap to clean the aerator. Avoid abrasive cleaners, harsh chemicals, or scouring pads, as these can damage the finish.
- Finish Preservation: For metallic parts, applying a non-abrasive wax, such as car wax, can help preserve the finish.
- Rinsing: Always rinse off any cleaners immediately after application to prevent residue buildup or damage.
- Mineral Buildup: If water flow decreases, the aerator screen may be clogged with mineral deposits. Unscrew the aerator, clean the screen with a soft brush under running water, or soak it in a vinegar solution to dissolve mineral buildup. Rinse thoroughly before reinstallation.
Troubleshooting
| Problem | Possible Cause | Solution |
|---|---|---|
| Low Water Flow | Clogged aerator screen due to debris or mineral buildup. | Remove and clean the aerator screen. Soak in vinegar if mineral deposits are present. |
| Leaking Around Aerator | Aerator not tightened sufficiently or damaged washer. | Gently tighten the aerator. If leaking persists, check for a properly seated or damaged washer and replace if necessary. |
| Irregular Water Stream | Partial blockage in the aerator or faucet spout. | Remove and thoroughly clean the aerator. Inspect the faucet spout for any obstructions. |
Specifications
- Model Number: 52613
- Brand: Moen
- Material: Brass
- Finish Type: Chrome
- Maximum Flow Rate: 1 Gallons Per Minute (GPM)
- Thread Size: 1/2 inch-14 NPT
- Product Dimensions: 0.95 x 0.95 x 0.71 inches
- Item Weight: 0.704 ounces
- Certifications: ANSI 372, NSF 61
Warranty Information
This Moen product is backed by Moen's One-Year Limited Warranty. For specific details regarding coverage and claims, please refer to the official Moen warranty documentation or contact Moen customer support.
Customer Support
For further assistance, technical support, or to inquire about replacement parts, please visit the official Moen website or contact their customer service department.
Moen Official Website: www.moen.com
About Moen
Moen is a leading brand in kitchen and bath fixtures, committed to designing and delivering exceptional water experiences. With a focus on innovation and quality, Moen products are trusted by homeowners and professionals alike.
Video: An official brand video from Moen, showcasing their commitment to water experiences and product design. This video highlights various Moen products and their role in daily life.
