1. Introduction
This manual provides instructions for the proper use and maintenance of the Nilfisk Advance 1407015040 Disposable Dust Bag Kit. This kit contains 10 genuine Nilfisk Advance white paper vacuum bags designed for optimal performance with Nilfisk and Euroclean GD930 series 4 gallon commercial canister vacuums.
These 2-ply paper bags are intended for dry pickup applications and offer standard filtration. Their gusseted construction supports high dust loading, reducing the frequency of bag changes during cleaning operations.
Figure 1: Nilfisk Advance 1407015040 Disposable Dust Bag Kit packaging. This image shows the product packaging containing 10 white paper vacuum bags.
2. Compatibility
These dust bags are specifically designed for the following vacuum cleaner models:
- Nilfisk Advance GD930
- Nilfisk Advance GD930 HEPA
- Nilfisk Advance GD930 S2
- Euroclean GD930
- Selected rebranded DP9000 and other 4-gallon commercial canister models that utilize the same bag collar and 4-gallon dust capacity.
Ensure your vacuum cleaner model is listed above or uses a compatible bag type before installation.
3. Setup and Installation
Follow these steps to install a new disposable dust bag into your compatible Nilfisk or Euroclean canister vacuum:
- Power Off: Ensure the vacuum cleaner is turned off and unplugged from the power outlet before attempting any installation or maintenance.
- Open Canister: Unlatch and remove the top cover of your vacuum cleaner to access the dust bag compartment.
- Remove Old Bag (if applicable): Carefully remove the full or old dust bag. Dispose of it according to local waste disposal guidelines.
- Insert New Bag: Take a new Nilfisk Advance 1407015040 dust bag. Align the bag collar with the inlet port inside the vacuum's dust compartment. Push the collar firmly onto the port until it is securely seated. Ensure the bag is fully unfolded inside the canister.
- Close Canister: Replace the top cover of the vacuum cleaner and secure the latches.
- Verify: Before operating, ensure the bag is correctly installed and the canister is properly sealed to prevent dust leakage and maintain optimal suction.
4. Operating Guidelines
These dust bags are designed for dry pickup applications only. Do not use these bags for wet vacuuming or to pick up liquids, as this can damage the bag and the vacuum cleaner.
- Dry Use Only: Exclusively for dry debris, dust, and particles.
- Capacity: The bags have approximately a 4-gallon capacity. Monitor the vacuum's suction power; a decrease often indicates a full bag.
- Filtration: These bags provide standard filtration, rated around 95.5 percent efficiency. For applications requiring higher filtration (e.g., HEPA), ensure your vacuum model is equipped with appropriate HEPA filters in addition to these bags.
5. Maintenance and Disposal
The Nilfisk Advance 1407015040 dust bags are single-use and disposable. They are not designed to be emptied and reused.
- Bag Replacement: Replace the dust bag when it is full or when you notice a significant reduction in vacuum suction power.
- Disposal: To dispose of a full bag, carefully remove it from the vacuum cleaner, ensuring the opening is sealed (if applicable to your vacuum model) to prevent dust from escaping. Dispose of the bag in a waste receptacle.
- Storage: Store unused bags in a cool, dry place away from direct sunlight and moisture to maintain their integrity.
6. Troubleshooting
If you experience issues with your vacuum cleaner's performance after installing a new dust bag, consider the following:
- Reduced Suction:
- Check if the dust bag is correctly installed and securely seated on the inlet port.
- Ensure the canister lid is properly closed and latched, creating an airtight seal.
- Verify that the dust bag is not overfilled. Replace it if necessary.
- Inspect the vacuum hose and attachments for blockages.
- Dust Leakage:
- Confirm the dust bag collar is firmly attached to the vacuum's inlet.
- Ensure the canister lid is sealed correctly.
- Check the dust bag for any tears or damage. Replace if damaged.
For persistent issues, refer to your vacuum cleaner's specific instruction manual or contact Nilfisk customer support.
7. Specifications
| Model Number | 1407015040 (Part Number: AX-AY-ABHI-10171) |
| Brand | Nilfisk |
| Material Type | Paper (2-ply) |
| Capacity | 4 Gallons |
| Filtration | Standard (approx. 95.5% efficiency) |
| Intended Use | Dry pickup applications only |
| Item Weight | 1.23 pounds (for the kit) |
| Product Dimensions | 14 x 8 x 2 inches (packaging) |
8. Warranty and Support
Specific warranty information for the Nilfisk Advance 1407015040 Disposable Dust Bag Kit is not provided in this manual. For details regarding product warranty, please refer to the original product packaging or contact Nilfisk customer service directly.
For technical support or further assistance, please visit the official Nilfisk website or contact their authorized service centers. Always provide your product model number (1407015040) and vacuum cleaner model when seeking support.
