1. Product Overview
The Hailo Compact-Box M is a space-saving, 4-gallon (15-liter) trash can designed for installation inside hinged-door cabinets. Its innovative lid-lift system automatically opens the lid when the cabinet door is opened, providing convenient and hygienic waste disposal. The unit includes a removable plastic inner bin for easy cleaning.
Figure 1: Hailo Compact-Box M Trash Can (closed view).
2. Setup and Installation
The Hailo Compact-Box M is designed for easy installation within hinged-door cabinets, suitable for both left and right-hand door mounting. Ensure your cabinet has a minimum width of 15.7 inches (40 cm) for proper fit and operation.
Required Tools:
- Pencil
- Ruler or measuring tape
- Screwdriver
- Drill (optional, for pilot holes)
Installation Steps:
- Prepare the Cabinet: Open the cabinet door fully. Identify the side where the trash can will be mounted (left or right).
- Mark Mounting Points: Use the provided template or measure carefully to mark the screw positions for the base bracket on the cabinet floor and the lid-lift mechanism on the cabinet side wall. Refer to the product dimensions for precise placement. For the 15L model, the lid-lift mechanism should be mounted approximately 311mm (12.2 inches) from the cabinet floor.
- Attach Base Bracket: Secure the base bracket to the marked positions on the cabinet floor using the provided screws. Ensure it is firmly attached and aligned.
- Attach Lid-Lift Mechanism: Secure the lid-lift mechanism to the marked positions on the cabinet side wall. This mechanism is crucial for the automatic lid opening feature.
- Position the Trash Can: Place the stainless steel trash can onto the base bracket. Ensure the lid arm connects securely to the lid-lift mechanism.
- Test Operation: Slowly open and close the cabinet door to verify that the trash can lid lifts and closes smoothly and automatically. The door should open to a maximum of 95 degrees for optimal lid operation.
Figure 2: Key dimensions for mounting the Hailo Compact-Box M.
Figure 3: The Hailo Compact-Box M installed inside a kitchen cabinet.
3. Operating Instructions
Using your Hailo Compact-Box M is straightforward due to its intelligent design.
Automatic Lid Operation:
Simply open your cabinet door. The integrated lid-lift system will automatically raise the trash can lid, providing immediate access for waste disposal. When the cabinet door is closed, the lid will automatically lower, sealing the contents and helping to contain odors.
Figure 4: The lid automatically opens as the cabinet door is pulled open.
Inner Bin Usage:
The trash can features a removable plastic inner bin. To empty or clean the bin, simply lift it out using its integrated handle. After emptying, place the inner bin back into the stainless steel housing, ensuring it sits securely.
Figure 5: The inner bin can be easily removed for emptying and cleaning.
4. Maintenance and Care
Regular cleaning and proper maintenance will ensure the longevity and hygienic operation of your Hailo Compact-Box M.
Cleaning the Inner Bin:
- Remove the inner bin from the main housing.
- Wash the plastic inner bin with warm water and a mild detergent.
- Rinse thoroughly and allow it to air dry completely before placing it back into the trash can.
Cleaning the Exterior:
- Wipe the stainless steel exterior with a soft, damp cloth.
- For stubborn marks or fingerprints, use a stainless steel cleaner according to its instructions.
- Avoid abrasive cleaners or scouring pads, as these can scratch the surface.
Mechanism Check:
- Periodically check the lid-lift mechanism and base bracket for any loose screws. Tighten if necessary.
- Ensure the lid arm moves freely and is not obstructed.
5. Troubleshooting
If you encounter any issues with your Hailo Compact-Box M, refer to the common problems and solutions below:
| Problem | Possible Cause | Solution |
|---|---|---|
| Lid does not open/close smoothly. | Misalignment of lid arm or mechanism; obstruction; incorrect screw installation. | Check alignment of the lid arm with the mechanism. Ensure no debris is obstructing movement. Review installation steps, particularly regarding any specific screws that might impede function. |
| Inner bin lifts off base when opening door. | Bin is too light or not properly seated. | Ensure the inner bin is fully seated on the base. If consistently an issue, consider adding a small weight to the bottom of the inner bin (e.g., a heavy object under the liner) if it does not interfere with function. |
| Lid or plastic components appear damaged. | Excessive force; material fatigue. | Avoid forcing the lid. If damage occurs, contact Hailo customer support for replacement parts or warranty claims. |
6. Specifications
Detailed specifications for the Hailo Compact-Box M Trash Can:
- Brand: Hailo
- Model Number: 3555-101
- Capacity: 15 Liters (approximately 4 Gallons)
- Color: Edelstahl (Stainless Steel)
- Opening Mechanism: Pull-Out (Lid-Lift)
- Material: Plastic, Stainless Steel
- Recommended Uses: Indoor
- Room Type: Kitchen
- Shape: Round
- Finish Type: Stainless Steel
- Item Weight: 1.7 Kilograms (3.74 pounds)
- Product Dimensions: 5.5"L x 4.5"W x 4.42"H (Note: These dimensions seem to be for packaging or a component, actual product dimensions for a 15L bin would be larger. Refer to installation diagram for cabinet space requirements.)
- With Lid: Yes
- Unit Count: 1.0 Count
- UPC: 787269142107
- Global Trade Identification Number: 04007126355515
7. Warranty and Support
Hailo products are manufactured to high-quality standards. This product comes with a limited warranty:
- Private Use Warranty: 5 years
- Commercial Use Warranty: 3 years
For warranty claims, technical assistance, or to order replacement parts, please contact Hailo customer support. You may also refer to the official user guide for additional information:
