MOTOROLA SOLUTIONS R7 Series Portable Two-Way Radio
Specifications
- Brand: MOTOTRBO
- Model: R7 Series
- Type: Portable Two-Way Radio
- Battery: Lithium Rechargeable Coin Cell Battery, 3.4 mAh
- Frequency: Tri-band Connectivity (GPS/BT/Wi-Fi/2.4-5 G)
Assembly Instructions
- Attach the Volume knob (Item 1.0) and Frequency knob (Item 2.0) to the device.
- Insert the Keypad (Item 3.0) into the designated slot.
- Secure all parts using the appropriate screws and retainers listed in Table 57.
Battery Installation
- Locate the Lithium Rechargeable Coin Cell Battery (Item 11.0).
- Insert the battery into the designated compartment according to the polarity markings.
- Secure the battery compartment with the O-Ring Main Seal (Item 12.0).
Operation
- Turn on the device by pressing the power button.
- Use the Volume knob to adjust the audio output.
- Press the necessary buttons on the Keypad to operate the radio functions.
5.6
Radio Exploded Mechanical Views and Parts Lists
5.6.1
Full Keypad Model Exploded View and Parts List
Figure 7: Full Keypad Model Exploded View
Table 57: Full Keypad Model Exploded View Parts List
| Item | Description | Part Number | |
| 1.0 | Volume knob | HW002889A01 | |
| 2.0 | Frequency knob | HW002890A01 | |
| 3.0 | Keypad | See the Additional Parts List Table on page 141 | |
| 4.0 | Countersunk Machined Screw M1.6 | FN000509A01 | |
| 5.0 | Front Kit | See the Additional Parts List Table on page 141 | |
| 5.01 | Front Housing Assembly FKP | 0104083J18 | |
| 5.02 | Speaker Mesh | HW003669A01 | |
| 5.03 | Speaker Assembly, 36 mm, 8 Ω | 0112908K01 | |
| 5.04 | Speaker Retainer | HW002770A01 | |
| 5.05 | Thread Forming Screw | FN000562A01 | |
| 5.06 | Antenna, PCB Assembly, Tri-band Connectivity (GPS/BT/Wi-Fi/2.4-5 G) | AN000389A01 | |
| 5.07 | Front Microphone Membrane Seal | SL000710A01 | |
| 5.08 | Front Microphone Boot Seal | SL000606A01 | |
| 5.09 | Antenna Retainer | HW002762A01 | |
| 5.10 | Front Microphone Backer Retainer | HW002844A01 | |
| 5.11 | Kapton Tape | HW002863A01 | |
| 5.12 | Display Poron Pad | HW003151A01 | |
| 5.13 | PCBA, GCAI Mini Flex | PA003038A01 | |
| 5.14 | Display Module-LC | See the Additional Parts List Table on page 141 | |
| 5.15 | Microphone Adhesive | HW003344A01 | |
| 5.16 | Side Display Pad | HW002772A01 | |
| 5.17 | PCBA (Ground Flex) | PA003292A01 | |
| 5.18 | Pad Back Display | HW002773A01 | |
| 5.19 | Display Retainer | BR000513A01 | |
| 5.20 | Keypad Retainer Screw | 0378212A04 | |
| 5.21 | Conductive Pad GCAI | HW002800A01 | |
| 5.22 | Conductive Retainer Pad | HW002790A01 | |
| 5.23 | Conductive Display Pad Flex | HW002792A01 | |
| 5.24 | Conductive PTT Pad | HW002791A01 | |
| 5.25 | Conductive LCD Pad | HW002788A01 | |
| 5.26 | Support Poron Pad | HW002966A01 | |
| 5.27 | Interface (FKP) Block | 0104083J15 | |
| 6.0 | Poron Pad, VCO Shield | HW003537A01 | |
Chapter 5: Disassembly and Reassembly Procedures
| Item | Description | Part Number | |
| 7.0 | GOB1 Service Kit | PMLN8203_S | |
| 7.01 | M2 Tapping Screw | 03012034001 | |
| 7.02 | GOB Flex PCB | PF003027A01 | |
| 8.0 | Main Flex Accessory PCBA | PA002996A01 | |
| 9.0 | Top Control Seal | SL000610A01 | |
| 10.0 | M2 Tapping Screw | 03012034001 | |
| 11.0 | Lithium Rechargeable Coin Cell Battery, 3.4 mAh | 60009265001 | |
| 12.0 | O-Ring Main Seal | SL000609A01 | |
| 13.0 | Top Control Retainer | HW002765A01 | |
| 14.0 | Top Control PCBA Flex | PA002952A01 | |
| 15.0 | Thermal Pad | 75012234001 | |
| 16.0 | Chassis Poron Pad | HW002848A01 | |
| 17.0 | Rear Microphone Boot Seal | SL000636A01 | |
| 18.0 | Rear Microphone Membrane Seal | SL000666A01 | |
| 19.0 | Chassis | CH000292A01 | |
| 20.0 | Battery Contact Seal | SL000611A01 | |
| 21.0 | Gasket | 3286058L01 | |
| 22.0 | Vent Seal Label | LB001662A01 | |
| 23.0 | Back Shroud Poron | HW002866A01 | |
| 24.0 | Shroud Retainer FKP and NKP | HW002766A01 | |
| 25.0 | Machined Shroud Screw | 0386104Z11 | |
| 26.0 | Nameplate | LB001707A01 | |
Table 58: Only Applicable for Model PMUD3531ACC
| Item | Description | Part Number | |
| 7.0 | PDT GOB Service Kit | PMLN8249_S | |
| 7.01 | M2 Tapping Screw | 03012034001 | |
| 7.02 | GOB Flex PCB | PF003027A01 | |
5.6.2
Non-Keypad Model Exploded View and Parts List
Figure 8: Non-Keypad Model Exploded View
Table 59: Non-Keypad Model Exploded View Parts List
| Item | Description | Part Number | |
| 1.0 | Volume knob | HW002889A01 | |
| 2.0 | Frequency knob | HW002890A01 | |
| 3.0 | Front Kit | See the Additional Parts List Table on page 141 | |
| 3.01 | Front Housing Assembly NKP | 0104083J19 | |
| 3.02 | Antenna, PCB Assembly, Tri-band Connectivity (GPS/BT/Wi-Fi/2.4-5 G) | AN000389A01 | |
| 3.03 | Front Microphone Membrane Seal | SL000710A01 | |
| 3.04 | Front Microphone Boot Seal | SL000606A01 | |
| 3.05 | Antenna Retainer | HW002878A01 | |
| 3.06 | Front Microphone Backer Retainer | HW002844A01 | |
| 3.07 | Keypad Retainer Screw | 0378212A04 | |
| 3.08 | PCBA, GCAI Mini Flex | PA003038A01 | |
| 3.09 | Speaker Mesh | HW002888A01 | |
| 3.10 | Speaker Assembly, 36 mm, 8 Ω | 0112908K01 | |
| Item | Description | Part Number | |
| 3.11 | Speaker Retainer Assembly | 0112980J66 | |
| 3.12 | Thread Forming Screw | FN000562A01 | |
| 3.13 | Microphone Adhesive | HW003344A01 | |
| 3.14 | Conductive PTT Pad | HW002791A01 | |
| 3.15 | Grounding Pad, Speaker | HW002897A01 | |
| 3.16 | Conductive Pad GCAI | HW002800A01 | |
| 3.17 | Conductive PTT Pad | HW003144A01 | |
| 3.18 | Poron Pad, GCAI Flex | HW002881A01 | |
| 3.19 | Poron Pad, PTT Flex | HW002880A01 | |
| 3.20 | PTT Top Poron Pad | HW002879A01 | |
| 3.21 | Stiffener PTT Flex | HW003254A01 | |
| 3.22 | NKP Spring Pad | HW003290A01 | |
| 3.23 | Interface (NKP) Block | 0104083J21 | |
| 3.24 | Keypad Retainer Screw | 0378212A04 | |
| 4.0 | GOB1 Service Kit, PCBA | PMLN8203_S | |
| 4.01 | M2 Screw, Tapping | 03012034001 | |
| 4.02 | M2 Tapping Screw | PF003027A01 | |
| 5.0 | Poron Pad, VCO Shield | HW003537A01 | |
| 6.0 | Main Flex Accessory PCBA | PA002996A01 | |
| 7.0 | Top Control Seal | SL000610A01 | |
| 8.0 | M2 Tapping Screw | 03012034001 | |
| 9.0 | Lithium Rechargeable Coin Cell Battery, 3.4 mAh | 60009265001 | |
| 10.0 | O-Ring Main Seal | SL000609A01 | |
| 11.0 | Top Control Retainer | HW002765A01 | |
| 12.0 | Top Control PCBA Flex | PA002952A01 | |
| 13.0 | Thermal Pad | 75012234001 | |
| 14.0 | Chassis Poron Pad | HW002848A01 | |
| 15.0 | Rear Microphone Membrane Seal | SL000666A01 | |
| 16.0 | Rear Microphone Boot Seal | SL000636A01 | |
| 17.0 | Chassis | CH000292A01 | |
| 18.0 | Battery Contact Seal | SL000611A01 | |
| 19.0 | Gasket | 3286058L01 | |
| 20.0 | Vent Seal Label | LB001662A01 | |
| 21.0 | Back Shroud Poron | HW002866A01 | |
| 22.0 | Shroud Retainer FKP and NKP | HW002766A01 | |
| 23.0 | Machined Shroud Screw | 0386104Z11 | |
| Item | Description | Part Number | |
| 24.0 | Nameplate | LB001707A01 | |
5.6.3
Simple Non-Keypad Model Exploded View and Parts List
Figure 9: Simple Non-Keypad Model Exploded View
Table 60: Simple Non-Keypad Model Exploded View Parts List
| Item | Description | Part Number | |
| 1.0 | Volume knob | HW002889A01 | |
| 2.0 | Frequency knob | HW002890A01 | |
| 3.0 | Front Kit | See the Additional Parts List Table on page 141 | |
| 3.01 | Front Housing Assembly NKP | 0104083J19 | |
| 3.02 | Front Microphone Membrane Seal | SL000710A01 | |
| 3.03 | Front Microphone Boot Seal | SL000606A01 | |
| 3.04 | Front Microphone Backer Retainer | HW002844A01 | |
| 3.05 | Antenna Retainer | HW002878A01 | |
| 3.06 | Keypad Retainer Screw | 0378212A04 | |
| 3.07 | Microphone Adhesive | HW003344A01 | |
| 3.08 | PCBA, GCAI Mini Flex | PA003038A01 | |
| Item | Description | Part Number | |
| 3.09 | Speaker Mesh | HW002888A01 | |
| 3.10 | Speaker Assembly, 36 mm, 8 Ω | 0112908K01 | |
| 3.11 | Speaker Retainer Assembly | 0112980J66 | |
| 3.12 | Thread Forming Screw | FN000562A01 | |
| 3.13 | Conductive PTT Pad | HW002791A01 | |
| 3.14 | Grounding Pad, Speaker | HW002897A01 | |
| 3.15 | Conductive Pad GCAI | HW002800A01 | |
| 3.16 | Conductive PTT Pad | HW003144A01 | |
| 3.17 | Poron Pad, GCAI Flex | HW002881A01 | |
| 3.18 | Poron Pad, PTT Flex | HW002880A01 | |
| 3.19 | PTT Top Poron Pad | HW002879A01 | |
| 3.20 | Stiffener PTT Flex | HW003254A01 | |
| 3.21 | NKP Spring Pad | HW003290A01 | |
| 3.22 | Interface (NKP) Block | 0104083J21 | |
| 3.23 | Keypad Retainer Screw | 0378212A04 | |
| 4.0 | Poron Pad, VCO Shield | HW003537A01 | |
| 5.0 | Main Flex Accessory PCBA | PA002996A01 | |
| 6.0 | Top Control Seal | SL000610A01 | |
| 7.0 | M2 Tapping Screw | 03012034001 | |
| 8.0 | O-Ring Main Seal | SL000609A01 | |
| 9.0 | Top Control Retainer | HW002765A01 | |
| 10.0 | Top Control PCBA Flex | PA002952A02 | |
| 11.0 | Thermal Pad | 75012234001 | |
| 12.0 | Chassis | CH000292A02 | |
| 13.0 | Battery Contact Seal | SL000611A01 | |
| 14.0 | Gasket | 3286058L01 | |
| 15.0 | Vent Seal Label | LB001662A01 | |
| 16.0 | Shroud Retainer Basic NKP | HW002766A02 | |
| 17.0 | Machined Shroud Screw | 0386104Z11 | |
| 18.0 | Nameplate | LB001783A01 | |
5.6.4
Additional Parts List Table
Table 61: Keypad
| Motorola Solutions Part Number | Description | Super Tanapa 20 |
| UHF | ||
| KP000218A01 | Keypad (Roman) | ● PMUE5722_AB ● PMUE5722_BB ● PMUE5724_AB |
| KP000218A02 | Keypad (Cyrillic) | PMUE5724_AG |
| KP000218A03 | Keypad (Arabic) | PMUE5724_AF |
| KP000218A05 | Keypad (Simplified Chi‐ nese) | PMUE5724_AC |
| KP000218A06 | Keypad (Traditional Chi‐ nese) | PMUE5724_AD |
| KP000218A07 | Keypad (Korean) | PMUE5724_AE |
| VHF | ||
| KP000218A01 | Keypad (Roman) | ● PMUD3491_AB ● PMUD3491_BB ● PMUD3493_AB |
| KP000218A02 | Keypad (Cyrillic) | PMUD3493_AG |
| KP000218A03 | Keypad (Arabic) | PMUD3493_AF |
| KP000218A05 | Keypad (Simplified Chi‐ nese) | PMUD3493_AC |
| KP000218A06 | Keypad (Traditional Chi‐ nese) | PMUD3493_AD |
| KP000218A07 | Keypad (Korean) | PMUD3493_AE |
| 800/900 | ||
| KP000218A01 | Keypad (Roman) | ● PMUF2000_AB ● PMUF2000_BB ● PMUF2002_AB |
| 350 MHz Band | ||
| KP000218A01 | Keypad (Roman) | ● PMUD3531_AB ● PMUD3532_BB |
| KP000218A05 | Keypad (Simplified Chi‐ nese) | PMUD3531_CC |
Table 62: Front Kit
| Motorola Solutions Part Number | Description | Super Tanapa 20 |
| UHF | ||
| PMLN8238_ | Front Kit FKP UL | ● PMUE5722_AB ● PMUE5722_BB |
| PMLN8239_ | Front Kit FKP Non-UL | ● PMUE5724_AB ● PMUE5724_AC ● PMUE5724_AD ● PMUE5724_AE ● PMUE5724_AF ● PMUE5724_AG |
| PMLN8243_ | Front Kit NKP UL | ● PMUE5723_AA ● PMUE5723_BA |
| PMLN8326_ | Front Kit NKP Basic | ● PMUE5741_AA ● PMUE5741_ZA ● PMUE5741_YA |
| VHF | ||
| PMLN8359_ | Front Kit FKP UL ITO Film | ● PMUD3491_AB ● PMUD3491_BB |
| PMLN8366_ | Front Kit FKP Non-UL ITO Film | ● PMUD3493_AB ● PMUD3493_AC ● PMUD3493_AD ● PMUD3493_AE ● PMUD3493_AF ● PMUD3493_AG |
| PMLN8243_ | Front Kit NKP UL | ● PMUD3492_AA ● PMUD3492_BA |
| PMLN8326_ | Front Kit NKP Basic | ● PMUD3494_AA ● PMUD3494_ZA ● PMUD3494_YA |
| 800/900 | ||
| PMLN8238_ | Front Kit FKP UL | ● PMUF2000_AB ● PMUF2000_BB |
| PMLN8239_ | Front Kit FKP Non-UL | PMUF2002_AB |
Table 63: Display Module
| Motorola Solutions Part Number | Description | Super Tanapa 20 |
| PMLN8243_ | Front Kit NKP UL | ● PMUF2001_AA ● PMUF2001_BA |
| PMLN8326_ | Front Kit NKP Basic | ● PMUF2003_AA ● PMUF2003_ZA |
| 350 MHz Band | ||
| PMLN8239_ | Front Kit FKP Non-UL | ● PMUD3531_AB ● PMUD3531_CC |
| PMLN8238_ | Front Kit FKP UL | PMUD3532_BB |
| PMLN8243_ | Front Kit NKP UL | PMUD3530_AA |
| Motorola Solutions Part Number | Description | Super Tanapa 20 |
| UHF | ||
| DM000160A01 | Display Module-LC, TFT- VA,240 Pixels, 320 Pixels (UL) | ● PMUE5722_AB ● PMUE5722_BB |
| DM000160A02 | Display Module-LC, TFT- VA, 240 Pixels, 320 Pixels (Non-UL) | ● PMUE5724_AB ● PMUE5724_AC ● PMUE5724_AD ● PMUE5724_AE ● PMUE5724_AF ● PMUE5724_AG |
| VHF | ||
| DM000160A03 | Display Module-LC, TFT- VA, 240 Pixels, 320 Pixels (UL Display and ITO Film) | ● PMUD3491_AB ● PMUD3491_BB |
| DM000160A04 | Display Module-LC, TFT- VA, 240 Pixels, 320 Pixels (Non-UL Display and ITO Film) | ● PMUD3493_AB ● PMUD3493_AC ● PMUD3493_AD ● PMUD3493_AE ● PMUD3493_AF ● PMUD3493_AG |
| 800/900 | ||
| DM000160A01 | Display Module- LC, TFTVA,240 Pixels, 320 Pixels (UL) | ● PMUF2000_AB ● PMUF2000_BB |
| Motorola Solutions Part Number | Description | Super Tanapa 20 |
| DM000160A02 | Display Module-LC, TFTVA, 240 Pixels, 320 Pixels (Non-UL) | PMUF2002_AB |
| 350 MHz Band | ||
| DM000160A01 | Display Module- LC, TFTVA,240 Pixels, 320 Pixels (UL) | PMUD3532_BB |
| DM000160A02 | Display Module-LC, TFTVA, 240 Pixels, 320 Pixels (Non-UL) | ● PMUD3531_AB ● PMUD3531_CC |
Documents / Resources
 | MOTOROLA SOLUTIONS R7 Series Portable Two Way Radio [pdf] Instruction Manual R7 Series, R7 Series Portable Two Way Radio, Portable Two Way Radio, Two Way Radio, Radio |