MSDS Report

Safety Data Sheet

Dorcy 10" 2,000-Lumen USB Rechargeable Flashlight with Powerbank, Black (41-4328) | Staples

Dorcy 10" Rechargeable Flashlight, Black/Red (41-4328) | Staples

Google Docs
Google Drive
Download [pdf]

File Info : application/pdf, 7 Pages, 374.47KB

24559736

Page 1 of 7

Report No.CCJC2020A171202
Material Safety Data Sheet

MSDS Report

Prepared For: Address: Product Name: Model : Nominal Voltage: Rated Capacity: Weight: Dimension :
Prepared By :
Report No.:

ShenZhenXinmengxingTechnology Co.,LTD
Room 302, Building A5, Yintian Industrial Zone, Yantian Community, Xixiang Street,Baoan District, Shenzhen
Li-ion Battery
103450
3.7V
2000mAh,7.4Wh
Approx.32.0g
10.0mm×34.0mm×50.0mm (T×W×L) Shenzhen CCJC Technology Co.,Ltd. 1st Floor, Xinbaoyi Industry and Trade Building B, Houting Community, Shajing Town, Bao'an District, Shenzhen City.Guangdong China CCJC2020A171202

Written by: Inspected by:

Approved by: Issue date:

2020-03-17

Shenzhen CCJC Technology Co., Ltd

Tel: (86-755)23707853 Http: //www.ccjctek.com Email: sales@ccjctek.com Add: 1st Floor, Xinbaoyi Industry and Trade Building B, Houting Community, Shajing Town, Bao'an District, Shenzhen City, Guangdong China

Page 2 of 7

Report No.CCJC2020A171202

Material Safety Data Sheet
Section 1 - Chemical Product and Company Identification

Product Name: Product Model: Manufacture: Address: Tel: Fax: Emergency Tel: E-mail:

Li-ion Battery 103450
ShenZhenXinmengxingTechnology Co.,LTD Room 302, Building A5, Yintian Industrial Zone, Yantian Community, Xixiang Street,Baoan District, Shenzhen +86-755-23079316 / +86-755-23079316 3552471764@qq.com

Classification of Danger Primary Route(s) of Exposure
Health Hazard

Section 2 - Hazards Identification
See section 14.
Eye, skin contact, ingestion.
The batteries are not hazardous when used according to the instructions of manufacturer under normal conditions. In case of abuse, there's risk of rupture, fire, heat, leakage of internal components, with could cause casualty loss. Abuses include but not limited to the following cases: charged for long time, short circuited, put into fire, whacked with hard object, punctured with acute object, crushed, and broken.

Section 3 Composition/Information on Ingredients

Chemical Composition Graphite
Polyethylene Rubber, butadiene styrene

CAS No. 7782-42-5 9002-88-4 61789-96-6

Concentration or concentration ranges (%)
16.21
3.3
0.48

Shenzhen CCJC Technology Co., Ltd

Page 3 of 7

Report No.CCJC2020A171202

Nickel Cellulose, carboxymethyl ether
Copper Phosphate(1-), hexafluoro-, lithium
Poly[imino(1-oxo-1,12dodecanediyl)], (nylon 12 chips)
1,1-Difluoroethylene polymer Polypropylene Aluminum
Lithium Cobalt Oxide (CoLiO2)

7440-02-0 9000-11-7 7440-50-8 21324-40-3 24937-16-4 24937-79-9 9003-07-0 7429-90-5 12190-79-3

Labeling according to EC directives. No symbol and risk phrase are required. Note: CAS number is Chemical Abstract Service Registry Number. N/A=Not apply.

Section 4 - First Aid Measures

1.61 0.46 9.73 18.42 0.90 1.48 1.78 9.83 35.8

Eye Skin Inhalation Ingestion

Flush eyes with plenty of water for at least 15 minutes, occasionally lifting the upper and lower eyelids. Get medical aid.
Remove contaminated clothes and rinse skin with plenty of water or shower for 15 minutes. Get medical aid. Remove from exposure and move to fresh air immediately. Use oxygen if available. Give at least 2 glasses of milk or water. Induce vomiting unless patient is unconscious. Call a physician.
Section 5 - Fire Fighting Measures

Characteristics of Hazard

Dusts at sufficient concentrations can form explosive mixtures with air. Combustion generates toxic fumes.

Hazardous Combustion Products

Carbon dioxide.

Fire-extinguishing Methods and Extinguishing Media
Attention in Fire-extinguishing

For small fires, use water spray, dry chemical, carbon dioxide or chemical foam.
Wear self-contained breathing apparatus in pressure-demand, MSHA/NIOSH (approved or equivalent) and full protective gear.

Shenzhen CCJC Technology Co., Ltd

Page 4 of 7

Report No.CCJC2020A171202

Section 6 - Accidental Release Measures

Personal Precautions, protective equipment, and emergency procedures
Environmental Precautions
Methods and materials for Containment
Methods and materials for cleaning up

In case of rupture. Attention! Corrosive material. Avoid contact with skin, eyes and clothing. Ensure adequate ventilation. Use personal protective equipment as required. Evacuate personnel to safe areas. Keep people away from and upwind of spill/leak. Refer to protective measures listed in Sections 7 and 8.
Prevent product from contaminating soil and from entering sewers or waterways.
Stop the leak if safe to do so. Contain the spilled liquid with dry sand or earth. Clean up spills immediately.
Absorb spilled material with an inert absorbent (dry sand or earth). Scoop contaminated absorbent into an acceptable waste container. Collect all contaminated absorbent and dispose of according to directions in Section 13. Scrub the area with detergent and water; collect all contaminated wash water for proper disposal.

Section 7 - Handling and Storage

Handling Storage Other Precautions

In case of rupture. Handle in accordance with good industrial hygiene and safety practice. Avoid contact with skin, eyes or clothing. Use personal protection equipment.
Store in a cool, dry, well-ventilated area away from incompatible substances. Store locked up. Keep out of the reach of children.
The battery may explode or cause burns, if disassembled, crushed or exposed to fire or high temperatures. Do not short or install with incorrect polarity.

Section 8 - Exposure Controls/Personal Protection

Engineering Controls
Personal Protective Equipment

Use adequate ventilation to keep airborne concentrations low. If used under conditions that generate particulates, the ACGIH TLV-TWA of 3mg/m3 respirable fraction (10mg/m3 total) should be observed.
Eye and Face Protection: None required for consumer use. If there is a risk of contact: Tight sealing safety goggles. Face protection shield. Skin and Body Protection: None required for consumer use. If there is a risk of contact: Wear protective gloves and protective clothing. Respiratory Protection: No protective equipment is needed under normal use conditions. If exposure limits are exceeded or irritation is experienced, ventilation and evacuation may be required.

Section 9 - Physical and Chemical Properties

Shenzhen CCJC Technology Co., Ltd

Page 5 of 7

Report No.CCJC2020A171202

Physical State
Change in condition pH Flash Point Flammability Relative density: Solubility (water) Solubility (other)

Appearance: Prismatic Color: Silver Odour: If leaking, smells of medical ether.
Not applicable as supplied. Not applicable unless individual components exposed. Not applicable unless individual components exposed. Not applicable unless individual components exposed. Not applicable unless individual components exposed. Not applicable unless individual components exposed.

Section 10 - Stability and Reactivity

Chemical Stability Possibility of Hazardous Reactions Conditions to Avoid Incompatible materials Hazardous Decomposition Products

Stable under recommended storage conditions. None under normal processing. Exposure to air or moisture over prolonged periods. Acids, Oxidizing agents, Bases. Carbon oxides.

Section 11 - Toxicological Information

Irritation Sensitization Reproductive Toxicity Toxicologically Synergistic Materials

In the event of exposure to internal contents, vapour fumes may be very irritating to the eyes and skin. Not Available.
Not Available.
Not Available.

General note:

Section 12 - Ecological Information
Do not allow undiluted product or large quantities of it to reach ground water, water course or sewage system.

Shenzhen CCJC Technology Co., Ltd

Page 6 of 7

Report No.CCJC2020A171202

Anticipated behavior of a chemical product in environment/possible environmental impact/ ecotoxicity

Not Available.

Section 13 - Disposal Considerations

Waste Treatment Attention for Waste Treatment

Recycle or dispose of in accordance with government, state & local regulations.
Deserted batteries couldn't be treated as ordinary trash. Couldn't be thrown into fire or placed in high temperature. Couldn't be dissected, pierced, crushed or treated similarly. Best way is recycling.

Section 14 - Transport Information

UN number

UN3480 or UN3481

Proper shipping name Class or division

Lithium ion batteries (including lithium ion polymer batteries) or Lithium ion batteries packed with equipment (including lithium ion polymer batteries) or Lithium ion batteries contained in equipment (including lithium ion polymer batteries)
9

Marine pollutant (Yes/No)

Packing group

N/A

Special precautions which a user needs to be aware of, or needs to comply with, in connection with transport or conveyance either within or outside their premises

ICAO / IATA:

Can be shipped by air in accordance with International Civil Aviation Organization (ICAO), TI or International Air Transport Association (IATA), DGR Packing Instructions (PI) 965 Section IB, or (PI) 966 Section II, or (PI) 967 Section II appropriate of IATA DGR 61st (2020 Edition) for transportation.

IMDG CODE:

The batteries are not restricted to IMDG Code 2018 Edition (Amdt39-18) according to special provision 188.

In addition, to be permitted in transport each lithium cell and battery types must have passed the applicable tests set out in Subsection 38.3 of the UN Manual of Tests and Criteria.

Section 15 - Regulatory Information

a) Dangerous Goods Regulations b) Recommendations on the Transport of Dangerous Goods-Model Regulations (20th revised edition) c) Recommendations on the Transport of Dangerous Goods-Manual of Tests and Criteria

Shenzhen CCJC Technology Co., Ltd

Page 7 of 7

Report No.CCJC2020A171202

d) International Air Transport Association (IATA) e) International Maritime Dangerous Goods (IMDG Code 2018 Edition Amdt 39-18) f) Technical Instructions for the Safe Transport of Dangerous Goods g) Classification and code of dangerous goods (GB 6944-2012) h) 2012 OSHA Hazard Communication Standard (29 CFR 1910.1200) i) Toxic Substance Control Act (TSCA) j) Code of Federal Regulations k) In accordance with all Federal, State and local laws
Section 16 - Other Information
The information above is believed to be accurate and represents the best information currently available to us. However, we makes no warranty of merchantability or any other warranty, express or implied, with respect to such information, and we assume no liability resulting from its use. Users should make their own investigations to determine the suitability of the information for their particular purposes. Although reasonable precautions have been taken in the preparation of the data contained herein, it is offered solely for your information, consideration and investigation. This material safety data sheet provides guidelines for the safe handling and use of this product; it does not and cannot advise on all possible situations, therefore, your specific use of this product should be evaluated to determine if additional precautions are required.
The data/information contained herein has been reviewed and approved for general release on the basis that this document contains no export controlled information.
Sample photo:

--End of report--

Shenzhen CCJC Technology Co., Ltd

iTextSharp 5.0.6 (c) 1T3XT BVBA