Parts Catalog. Issued: Jan 18, 2021 ... 2021 Invacare Corporation, Elyria, Ohio. Invacare, the Medallion ... 1134866-NLA. NLA - Owner's Manual - AWQ. 1. 1. A.
Parts Catalog. Issued: Jan 18, 2021. Oxygen Concentrator. ... © 2021 Invacare Corporation, Elyria, Ohio. Invacare, the Medallion Design and Yes, you can. are...
Parts Catalog Issued: Apr 21, 2021 Oxygen Concentrator International PlatinumTM S (IRC5LXO2 AWQ) Parts Catalog Usage Guide The information contained in this document is subject to change without notice. This catalog contains service parts for Form No. 06-104. If you have any questions regarding this catalog, please contact one of our Customer Service Representatives. For Customer Service Support Call: 1-800-333-6900 For Faxed In Orders Call: 1-800-678-4682 or 1-440-366-0709 For Technical Service Call: 1-800-832-4707 Literature Can Be Found at: www.invacare.com or 1-800-828-6272 SYMBOL DEFINITION Throughout this catalog you will notice letters to draw your attention to specific footnotes which are located at the bottom of the page or below specified charts. Examples: A,B,C etc. = NOTE: = NLA = Special Comments General information pertaining to that specific page No Longer Available HARDWARE MEASUREMENTS The measurements for the hardware will be listed as follows: Screws, Bolts Diameter X Thread Count/Pitch X Length Washers Inside Diameter X Outside Diameter X Thickness Spacers Inside Diameter X Outside Diameter X Length For your convenience, we have supplied an area for you to list your Invacare Representatives. Name Phone Numbers © 2021 Invacare Corporation, Elyria, Ohio. Invacare, the Medallion Design and Yes, you can. are registered trademarks of the Invacare Corporation. Platinum is a trademark of Invacare Corporation. Palnut is a registered trademark of Transtechnology Corporation. Information is subject to change without notification. Palnut is a registered trademark of Transtechnology Corporation. Information is subject to change without notification Form No. 06-104 1 To order call toll free 1-800-333-6900, or www.invacare.com TABLE of CONTENTS Description Compressor .............................................................................................................................. Control Panel - Front View ....................................................................................................... Control Panel - Rear View ........................................................................................................ Packaging & Literature ............................................................................................................. Shroud - Bottom ....................................................................................................................... Shroud - Top ............................................................................................................................ Sieve Beds & Product Tank ..................................................................................................... Sound Box & Manifold .............................................................................................................. Page Number 4 6 8 3 12 10 14 16 Form No. 06-104 2 To order call toll free 1-800-333-6900, or www.invacare.com Packaging and Literature Item Number Note A A A Part Number 1134866-NLA 1164896 1112296-NLA NOTE: A - Not Shown. Description NLA - Owner's Manual - AWQ Owner's Manual - Hungarian NLA - Kit, Packaging w/ Carton, Inserts and Owner's Manual Quantity Per Package Assembly 1 1 1 1 1 1 Form No. 06-104 3 To order call toll free 1-800-333-6900, or www.invacare.com Compressor Form No. 06-104 4 To order call toll free 1-800-333-6900, or www.invacare.com Compressor Item Number Note Part Number Description 1 A,B 1136960-NLA NLA - Tech Only - Compressor with Mounting Hardware 2 1119590-NLA NLA - Tech Only - Heat Exchanger Assembly 3 1108819 Fitting, Elbow (1/2" Beaded Hose x 1/4" NPT) 4 1150580 Pin, Spring Retainer 4 1106446-NLA NLA - Pin, Spring Retainer 5 1107411 Glide, Pin 6 1105504-NLA NLA - Spring, Compressor Mount 6 1150581 Spring, Compressor Mount 7 C 1186230 Kit, Compressor Restraint Bracket w/ Hardware 8 Bracket, Restraint, Compressor 9 NLA - Bumper, Bracket 10 Bumper, Restraint Bracket, Compressor 11 NLA - Screw, Phillips Hex Washer Head w/ Patch (1/4-20 x 3/4") 12 Retainer, Push (1/4") D 1153688 Kit, Compressor Rebuild w/ Instruction Sheet Compressor Rebuild - Thomas Instruction Sheet, Thomas Rebuild 2660-2650 NOTE: A - Includes Compressor and Items 3 - 6. B - Used with IRC5LXO2AWQ. C - Includes Items 8 - 12. D - Not Shown. Quantity Per Package Assembly 1 1 1 1 1 1 1 4 1 4 1 4 1 4 1 4 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 Form No. 06-104 5 To order call toll free 1-800-333-6900, or www.invacare.com Control Panel - Front View Form No. 06-104 6 To order call toll free 1-800-333-6900, or www.invacare.com Control Panel - Front View Item Number Note Part Number Description Quantity Per Package Assembly 1 1128404 Screw, Phillips Hex Washer Head (#8-32 x 3/8") 1 2 2 2000507 Palnut (9/16-18) 1 3 3 1110824-NLA NLA - Tech Only - Circuit Breaker (4 AMP) 1 1 4 2002939-NLA NLA - Tech Only - Hour Meter Assembly with Clip 1 1 5 1139950 Switch, Powe On/Off 1 1 6 1121475-NLA NLA - Label, Control Panel, English - IRC5LX02AW 1 1 6 1121476 Label, Control Panel, Spanish - IRC5LXO2AW 1 1 6 1121477 Label, Control Panel, French - IRC5LXO2AW 1 1 6 1121478 Label, Control Panel, German - IRC5LXO2AW 1 1 6 1121479 Label, Control Panel, Port/Brazil - IRC5LXO2AW 1 1 6 1121480 Label, Control Panel, Norwegian - IRC5LXO2AW 1 1 6 1121481 Label, Control Panel, Finland - IRC5LXO2AW 1 1 6 1121482 Label, Control Panel, Danish - IRC5LXO2AW 1 1 6 1142731 Label, Control Panel, Italian - IRC5LXO2AW 1 1 6 1142732 Label, Control Panel, Polish - IRC5LXO2AW 1 1 6 1142733 Label, Control Panel Text, Czech - IRC5LXO2AW 1 1 6 1142734 Label, Control Panel, Greek - IRC5LXO2AW 1 1 6 1142735 Label, Control Panel, Dutch - IRC5LXO2AW 1 1 6 1142736 Label, Control Panel, Swedish - IRC5LXO2AW 1 1 6 1164897 Label, Control Panel, Hungarian - IRC5LXO2AW 1 1 7 C 1110561 Flowmeter without Palnuts - 5 Liter 1 1 8 2000473 Connector, Barbed (1/4") 1 1 9 1140334-NLA NLA - Decal, Logo - Platinum S AWQ 1 1 10 A 1128379 Package, Knob, Flowmeter, Silver w/ Black Swish 10 1 (Pkg. of 10) 10 B 1128380 Package, Knob, Flowmeter, Black w/ Silver Swish 10 1 11 1101591 Support, Control Panel 1 2 12 1112562-NLA NLA - Tech Only - Seal, Circuit Breaker 1 1 NOTE: A - Knob is Silver with Black increasing flow symbol. Use on flowmeters with Phillips Head Indented Screw on top. B - Knob is Black with Silver increasing flow symbol. Use on flowmeters with Slotted Head Screw on top. C - Palnuts are not included, refer to Item #2. Form No. 06-104 7 To order call toll free 1-800-333-6900, or www.invacare.com Control Panel - Rear View Form No. 06-104 8 To order call toll free 1-800-333-6900, or www.invacare.com Control Panel - Rear View Item Number Note Part Number Description 1 B 1140405 Control Panel Assembly 2 D 1105385-NLA NLA - Tech Only - Transformer E 1105391-NLA NLA - Transformer Kit 3 A 1110779-NLA NLA - Tubing Assembly, Check Valve Discharge 4 1108815-NLA NLA - Tubing, Silicon (1/4 x 16-1/4") 5 1108809 Tubing, PVC (1/4 x 12-3/4") 6 2001902-NLA NLA - Screw, Phillips Pan Head (#4-40 x 1/4") 7 1148686 PCB Control Assembly 8 1102696 Screw, Phillips Pan Head SEMS (#8-32 x 3/8") C 1121280-NLA NLA - Tech Only - Harness, Wire, 10 Pin NEC 9 1143144 Tubing, PVC (1/4 x 5") 10 2000436 Check Valve, Barb (5/16") 11 P0750X030 Filter, Patient HEPA Outlet 12 1110473 Tubing, PVC (1/4 x 1-3/4") 13 2001682 Tie Wrap (8" L) NOTE: A - Includes Tubing (2 ea.) Check Valve, Elbow and Tie Wraps. B - Includes Control Panel with 1-12 (Front View) and 2-9 (Rear View). C - Not Shown. D - Individual item no longer available, refer to Transformer Kit Part #1105391 for replacement. E - Kit includes Transformer, Nuts and Insulator. Quantity Per Package Assembly 1 1 1 1 1 1 1 1 1 1 1 1 1 2 1 1 1 2 1 1 1 1 1 1 1 1 1 2 1 2 Form No. 06-104 9 To order call toll free 1-800-333-6900, or www.invacare.com Shroud Top Form No. 06-104 10 To order call toll free 1-800-333-6900, or www.invacare.com Shroud Top Item Number Note Part Number Description Quantity Per Package Assembly 1 A,B,C 1108803 Cabinet Cover without Tie Wraps 1 1 2 1070050 Tie Wrap (3-29/32" L) 1 1 3 60125500 Cord, Elastic 1 1 4 1115868 Kit, Cabinet Handle 1 1 Handle, Top, Warm Grey 1 1 NLA - Screw, Hex Head Tap (1/4-15 x 3/4") 1 2 5 B,C 1172003 Package, Power Cord Strap w/ Hardware 1 1 6 Strap, Hook and Loop 10 1 7 Rivet, Plastic 10 1 NLA - Retainer, Push On 10 1 8 1107400 Grid, Filter 1 2 9 1107412 Filter, Cabinet 1 2 10 1110766 Door, Filter Access with Foam Gasket 1 1 NOTE: C 1112296-NLA NLA - Kit, Packaging w/ Carton, Inserts and 1 1 Owner's Manual A - Includes Cabinet and Items 2-9. B - After 6/28/07, the Hook and Loop Strap are no longer used on the Cabinet Cover Assembly. If Hook and Loop Strap is needed you must order Package, Power Cord Strap w/ Hardware, Part Number 1172003. C - Not shown. Form No. 06-104 11 To order call toll free 1-800-333-6900, or www.invacare.com Shroud - Bottom Form No. 06-104 12 To order call toll free 1-800-333-6900, or www.invacare.com Shroud - Bottom Item Number Note Part Number Description 1 C 1108804-NLA NLA - Base, Compressor, Maroon 1 C 1134174-NLA NLA - Tech Only - Base, Compressor, Black 2 1104151 Fitting, Hose Barb with Nut (1/8") 3 1108211 Cap, End, Dust, Green 4 1105515-NLA NLA - Tech Only - Module, Inlet (15A/ 250 VAC) 5 1110426 Caster Assembly (2") 6 2000576 Stand-Off, Twist-Lok (1/2") 7 1137257-NLA NLA - Tech Only - Foam, Base - AWQ 8 2002360-NLA NLA - Grommet, Plastic 8 2000360 Grommet, Plastic 9 2000508 Screw, Phillips Truss Head Self Tap (#8-32 x 5/8") 10 1136948-NLA NLA - Exhaust, Baffle, Plastic 11 B 1119595-NLA NLA - Tech Only - Kit, Foam Base 12 A 1131308-NLA NLA - Tech Only - Cord, Power, Continental Europe 12 A 1062794-NLA NLA - Cord, Power - Argentina, Australia, Peoples Republic of China and New Zealand 12 A 1062793-NLA NLA - Cord, Power - Hong Kong, Singapore and Vietnam 12 A 1071398 Cord, Power - Israel 12 A 1102634 Cord, Power - India NOTE: A - Select Line Cord desired. B - Kit includes Right Inner, Right Outer and Left Outer Base Foam. C - Base color has changed to black after 5/10/07. Quantity Per Package Assembly 1 1 1 1 1 1 1 1 1 1 1 4 1 1 1 1 1 4 1 4 1 4 1 1 1 1 1 1 1 1 1 1 1 1 1 1 Form No. 06-104 13 To order call toll free 1-800-333-6900, or www.invacare.com Sieve Beds and Product Tank Form No. 06-104 14 To order call toll free 1-800-333-6900, or www.invacare.com Sieve Beds and Product Tank Item Number Note Part Number Description Quantity Per Package Assembly 1 A,K 1101707 Sieve Bed Assembly (Pair) 1 1 2 1110774 Tubing, PVC (1/4 x 2-1/2") 1 2 3 2001682 Tie Wrap (8" L) 1 9 4 E 1137252-NLA NLA - P.E. Valve Assembly 1 1 5 1108783 Tubing, Braided (1/2 x 23") 1 1 6 2001652 Clamp, Plastic (1/2") 1 2 7 1002807 Clamp, Hose 1 3 8 1075666 Screw, Socket Button Head Cap, Regulator (8-32 x 1 4 3/8") 9 1108784 Tubing, Braided (1/2 x 20-1/4") 1 1 10 B 1104310 Kit, Check Valve 1 1 Clamp, Hose 1 2 Tie Wrap (3-29/32" L) 1 1 Instruction Sheet 1 1 Check Valve, Barb (5/16") 1 2 Tie Wrap (8" L) 1 9 Tube, Clear (1/4") 1 1 11 D,F 1130681 Product Tank Assembly 1 1 12 C,F 1116433 HomeFill Tubing Assembly 1 1 13 G 1075506-NLA NLA - Regulator 1 1 13 H 1162040 Kit, Regulator w/ SenO2 1 1 NLA - Regulator 1 1 Screw, Socket Button Head Cap, Regulator (8-32 x 1 4 3/8") NLA - O-Ring (11/64" I.D.) 1 2 14 1108809 Tubing, PVC (1/4 x 12-3/4") 1 1 15 1070050 Tie Wrap (3-29/32" L) 1 1 16 J 1154223-NLA NLA - Tech Only - Restraint, Sieve Bed 1 1 17 1128404 Screw, Phillips Hex Washer Head (#8-32 x 3/8") 1 1 18 P0870X490 Washer, Flat (#8) 1 1 19 J 1154224-NLA NLA - Tech Only - Support, Sieve Bed 1 2 NOTE: A - Includes (2) Sieve Beds, (2) Clamps, (2) Hose Clamps and (4) Tie Wraps. B - Includes (2) Check Valve, (1) Cable Tie, (2) Hose Clamps, Tubing and (9) Tie Wraps. C - Includes Fitting, Tubing, Restrictor and Filter. D - Includes Product Tank, Cap with O-Ring, Snap Ring and Regulator. E - Includes Valve, Tubing and Tie Wraps. F - Due to design change the HomeFill Tubing Assembly has changed from a 8-1/2" to a 18" Hose, with a removal of the fitting as well. The change is compatible with existing units. G - Regulator does have an O2 bleed port H - Kit includes the Regulator, (4) Screws, (2) O-Rings J - Not available as US ISP, purchased directly from China by Europe. K - May contain reactivated sieve. Form No. 06-104 15 To order call toll free 1-800-333-6900, or www.invacare.com Sound Box & Manifold Form No. 06-104 16 To order call toll free 1-800-333-6900, or www.invacare.com Sound Box & Manifold Item Number 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 Note A,B D C,E C,E G Part Number Description 1136943-NLA NLA - Tech Only - Fan, Exhaust 1141964 Kit, Fan Mounting Hardware Grommet, Isolator w/ Spacer Washer (#10) NLA - Screw, Phillips Pan Head (10-24 x 3/4") 1108783 Tubing, Braided (1/2 x 23") 1108784 Tubing, Braided (1/2 x 20-1/4") 2001765 Harness, Horn/Alarm 1136944-NLA 2001682 NLA - Tech Only - Manifold/Valve and Muffler Assembly Tie Wrap (8" L) 1136945-NLA NLA - Tech Only - Muffler/Y-Tube Assembly P0875X560-NLA NLA - Boot, Terminal 1141835 Kit, Capacitor 10 MFD NLA - Tech Only - Capacitor, 10 MFD Clamp, Cap Screw, Phillips Pan Head (8-32 x 1/2") Washer, Flat (#8) NLA - Nut, Keps (#6-32) NLA - Boot, Terminal Tie Wrap (3-29/32" L) NLA - Screw, Phillips Hex Washer Head (#8-32 x 3/8") Tie Wrap (8" L) P0876X026 Clamp, Hose 1108822 Elbow, PVC Formed (1/2 x 2-1/2 x 2-1/2") 1108810 Screw, Hi-Lo Six Lobe Drive (#10-16 x 5/8") 1141965-NLA NLA - Kit, Inlet Resonator Tube, Inlet, Top Resonator Tube, Inlet, Bottom Tie Wrap (8" L) Tie Wrap (11-3/4") Screw (8-32 x 3/8") Mount, Cable Tie Stand-Off NLA - Screw, Phillips Pan Head (#8-32 x 3/8") 1105552 Kit, 4 Way Valve/Manifold Service NLA - Manifold Assembly Kit, 4-Way Valve w/ Screws Hose, Reinforced Silicon (1/2 x 8-1/2") Tubing, Reinforced Braided (1/2x 4-1/8") Clamp, Hose Tubing, Reinforced Braided (1/2 x 26") Tie Wrap (8" L) Form No. 06-104 17 To order call toll free 1-800-333-6900, or www.invacare.com Quantity Per Package Assembly 1 1 1 1 4 1 4 1 4 1 1 1 1 1 1 1 1 1 1 5 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 2 1 1 1 1 1 7 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 2 1 1 1 2 1 6 Sound Box & Manifold Item Number Note Part Number Description Quantity Per Package Assembly Clamp, Plastic (1/2") 1 2 Bushing, Step (1/2") 1 4 Washer, Flat (#8) 1 2 NLA - Screw, Phillips Pan Head (#8-32 x 3/4") 1 2 NLA - Resistor Service Assembly 1 1 Tie Wrap (3-29/32" L) 1 4 Instruction Sheet 1 1 15 H 1101141 Kit, 4-Way Valve w/ Screws 1 1 C 1101141R Valve, Reconditioned 1 1 C 1101141E-NLA Kit, Valve - Warranty Replacement 1 1 Valve, Reconditioned 1 1 Gasket 1 1 Screw, Socket Head (M5 x .8 x 2mm) 1 4 16 1106675 Coupling, Inlet Filter 1 1 17 2000812 Seal, Foam 1 2 18 F P0750X030 Filter, Patient HEPA Outlet 1 1 19 1115183 Partition Assembly 1 1 20 1128404 Screw, Phillips Hex Washer Head (#8-32 x 3/8") 1 1 21 1108815-NLA NLA - Tubing, Silicon (1/4 x 16-1/4") 1 1 22 1131249 Filter, Inlet Sound Reduced 1 1 23 2000799 Adapter with Tubing for Humidifier Bottle 1 1 24 1125477-NLA NLA - Tech Only - Bracket, Soundbox 1 1 NOTE: A - Manifold is not available as an individual item, order item #6 Manifold/Valve. B - Includes Manifold Assembly and items 3-4, 7-8, 11-12 and 15. C - Not Shown. D - Kit includes Capacitor, Clamp, Boot, Washer, Nut, Screws, Cable Tie and Tie Wrap. E - Used with the Manifold/Valve Assembly. F - After 6/14/07 the Hepa Filter was moved to the inside of cabinet, located between the Flow Meter and the Patient Outlet Barb. See "Rear Control Panel" category to view reflective changes. G - Used with Concentrators manufactured before January 31, 2001. H - Used with Concentrators manufactured after February 1, 2001. Form No. 06-104 18 To order call toll free 1-800-333-6900, or www.invacare.com Invacare Corporation One Invacare Way Elyria, Oh USA 44036-2125 800-333-6900 Technical Support 800-832-4707 Customer Service 800-333-6900 www.invacare.com Literature Orders 800-333-6900 © 2021 Invacare Corporation. All rights reserved. Republication, duplication or modification in whole or in part is prohibited without prior written permission from Invacare. Trademarks are identified as TM and ®. All trademarks are owned by or licensed to Invacare Corporation or its subsidiaries unless otherwise noted. Palnut is a registered trademark of Transtechnology Corporation. Information is subject to change without notification. (Revised 04/21/21) Form No. 06-104