Extremely Flammable Aerosol. Contains gas under pressure; may explode if heated. May be fatal if swallowed and enters airways. Causes skin irritation.
SC1 High Gloss Coating | 17.2oz Aerosol | Maxima 78920 | McKenzie's
SAFETY DATA SHEET Page 1 of 8 Released: 2015-06-01 SC1 Version: 1.1 Revision Date: 2015-05-28 1. IDENTIFICATION OF THE SUBSTANCE / APPLICATION AND THE COMPANY Supplier: Maxima Racing Oils 9266 Abraham Way Santee, CA 92071 USA +1 619 449 5000 Product Name: SC1 Article Number: 78920 Generic Chemical Name: Aerosol Applications: Detailer Emergency Telephone: CHEMTREC +1 703 527 3887 (24 hours) 2. HAZARDS IDENTIFICATION GHS Classification Flammable Aerosol Gas Under Pressure Aspiration Toxicity Skin Irritation Specific Target Organ Toxicity Single Exposure Category 1 Liquefied Gas Category 1 Category 2 Category 3 (Nervous system effects) Note: This product is a consumer product and is labeled in accordance with the US Consumer Product Safety Commission regulations which take precedence over OSHA Hazard Communication labeling. The actual container label will not include the label elements below. The labeling below applies to industrial/professional products. Label Elements: GHS Pictogram Signal Word DANGER! Hazard Statements Precautionary Statements Prevention Extremely Flammable Aerosol. Contains gas under pressure; may explode if heated. May be fatal if swallowed and enters airways. Causes skin irritation. May cause drowsiness or dizziness. Keep away from heat, sparks, open flames, hot surfaces No smoking. Do not spray on an open flame or other ignition source. Pressurized container: Do not pierce or burn, even after use. Avoid breathing vapors or mists. SAFETY DATA SHEET Page 2 of 8 Released: 2015-06-01 SC1 Version: 1.1 Revision Date: 2015-05-28 Wash thoroughly with soap and water after handling. Use only outdoors or in a well-ventilated area. Wear protective gloves. Response Storage Disposal Other Hazards IF SWALLOWED: Immediately call a POISON CENTER or physician. Do NOT induce vomiting. IF ON SKIN: Wash with plenty of soap and water. If skin irritation occurs: Get medical attention. Take off contaminated clothing and wash before reuse. IF INHALED: Remove person to fresh air and keep at rest in a position comfortable for breathing. Call a POISON CENTER or physician if you feel unwell. Store locked up. Protect from sunlight. Do not expose to temperatures exceeding 50°C/122°F. Store in a well-ventilated place. Dispose of contents and container in accordance with local and national regulations. None 3. COMPOSITION / INFORMATION ON INGREDIENTS Components Content % CAS Number US Hazcom 2012/ GHS Classification Naphtha (petroleum), light 64741-66-8 40-50 Flammable Liquid Category 2 alkylate Aspiration Toxicity Category 1 Skin Irritant Category 2 Specific Target Organ Toxicity Single Exposure Category 3 (Nervous system effects) Liquefied Petroleum Gas (Propane, 68476-86-8 35-45 Flammable Gas Category 1 Isobutane) Gas Under Pressure, Liquefied Gas Note: The specific identity and/or exact percentage been withheld as a trade secret. 4. FIRST-AID MEASURES Inhalation Skin Contact Eye Contact If irritation is experienced, move to fresh air. Get medical attention if irritation or other symptoms develop and persist. Wash with soap and water for several minutes. Remove contaminated clothing and wash before reuse. If irritation develops and persists, get medical attention. Flush thoroughly with water. Remove contact lenses if present after the first 5 minutes and continue flushing for several more minutes. Get medical attention if irritation persists. SAFETY DATA SHEET Page 3 of 8 Released: 2015-06-01 SC1 Version: 1.1 Revision Date: 2015-05-28 Ingestion Most Important Symptoms Indication of Immediate Medical Attention Needed Notes to Physician Aspiration Hazard. DO NOT induce vomiting. Call physician or poison control center. May cause eye, skin, and respiratory irritation. Skin contact may cause drying of the skin. Inhalation of mists or vapors may cause headache, dizziness, nausea and other symptoms of central nervous system depression. Harmful or fatal if swallowed. If swallowed, may be aspirated and cause lung damage. Immediate medical attention is needed for ingestion. Treat appropriately. 5. FIRE FIGHTING MEASURES Suitable Extinguishing Media Specific Hazards Arising From The Chemical Special Protective Equipment And Precautions For FireFighters Use water fog, dry chemical, carbon dioxide or foam. Do not use water jet or flooding amounts of water. Burning product will float on the surface and spread fire. Extremely flammable aerosol. Contents under pressure. Highly flammable liquid and vapor. Keep away from ignition sources and open flames. Exposure of containers to extreme heat and flames can cause them to rupture often with violent force. Vapors can cause a flash fire. Vapors are heavier than air and may travel along surfaces to remote ignition sources and flash back. Combustion will produce oxides of carbon and silicon, smoke fumes, and unburned hydrocarbons. A vapor and air mixture can create an explosion hazard in confined spaces. Firefighters should always wear positive pressure self-contained breathing apparatus and full protective clothing. Cool fire-exposed containers with water. Use shielding to protect against bursting containers. 6. ACCIDENTAL RELEASE MEASURES Personal Precautions Environmental Hazards Methods/Materials for Cleaning up Wear appropriate protective clothing (see Section 8). Eliminate all sources of ignition and ventilate area Not determined Leaking cans should be placed in a plastic bag or open pail until the pressure has dissipated. Contain and collect liquid with an inert absorbent and place in a container for disposal. Clean spill area thoroughly. Report spills to authorities as required. 7. HANDLING AND STORAGE Precautions for Safe Avoid contact with eyes and skin. Avoid breathing vapors or aerosols. Use SAFETY DATA SHEET Page 4 of 8 Released: 2015-06-01 SC1 Version: 1.1 Revision Date: 2015-05-28 Handling: Conditions for Safe Storage only with adequate ventilation. Keep away from heat, sparks, pilot lights, hot surfaces and open flames. Unplug electrical tools, motors and appliances before spraying or bringing the can near any source of electricity. Electricity can burn a hole in the can and cause contents to burst into flames. To avoid serious burn injury, do not let the can touch battery terminals, electrical connections on motors or appliances or any other source of electricity. Wash thoroughly with soap and water after handling. Keep containers closed when not in use. Keep out of the reach of children. Do not puncture, crush or incinerate containers, even when empty. Store in a cool, well-ventilated area, away from incompatible materials. Do not store above 120F or in direct sunlight. U.F.C (NFPA 30B) Level 3 Aerosol. Store away from oxidizers. 8. EXPOSURE CONTROLS/PERSONAL PROTECTION Exposure Limits Naphtha (petroleum), light alkylate Propane Isobutane 1200 mg/m3 TWA (total hydrocarbons) (Supplier Recommended) 1000 ppm TWA OSHA PEL 1000 ppm STEL ACGIH TLV The Following Controls are Recommended for Normal Consumer Use of this Product Appropriate Use in a well-ventilated area. Engineering Controls Personal Protection Respiratory None needed for normal use with adequate ventilation. Protection: Eye Protection: Avoid eye contact. Always spray away from your face. Skin/Body Protection: Avoid prolonged skin contact. Chemical resistant gloves recommended for operations where skin contact is likely. For Bulk Processing or Workplace Use the Following Controls are Recommended Appropriate Use adequate general and local exhaust ventilation to maintain exposure Engineering Controls levels below that occupational exposure limits. Personal Protection Respiratory None required if ventilation is adequate. If the occupational exposure limits Protection: are exceeded, wear a NIOSH approved respirator. Respirator selection and use should be based on contaminant type, form and concentration. Follow OSHA 1910.134, ANSI Z88.2 and good Industrial Hygiene practice. Eye Protection: Safety goggles recommended where eye contact is possible. Skin/Body Protection: Wear chemical resistant gloves. Work/Hygiene Wash with soap and water after handling. Practices: SAFETY DATA SHEET Page 5 of 8 Released: 2015-06-01 SC1 Version: 1.1 Revision Date: 2015-05-28 9. PHYSICAL AND CHEMICAL PROPERTIES Appearance Color Odor Odor Threshold pH Freezing Point Boiling Point Flash Point Evaporation Rate Flammability (solid, gas) Upper Explosion Limit Lower Explosion Limit Vapor Pressure Vapor Density (Air=1) Relative Density Solubility Partition Coefficient: noctanol/water Auto Ignition Temperature Decomposition Temperature Volatile Organic Compounds (VOC) Viscosity Pour Point Liquid Clear Pleasant odor Not established Not applicable Not established >95°F (>35°C) (Concentrate) 44.6°F (7°C) (Concentrate) Not established Flammable Aerosol 6.2% 0.9% 14.24 mmHg @ 68°F (20°C) (Concentrate) >1 Not established Insoluble in water Not established Not established Not established 86% Not established Not established 10. STABILITY AND REACTIVITY Reactivity Not reactive under normal conditions Chemical Stability Stable. Possibility of Hazardous May react with strong oxidizers generating heat. Reactions Conditions to Avoid Avoid heat, sparks, flames and other sources of ignition. Do not puncture or incinerate containers. Incompatible Materials Strong oxidizing agents. Hazardous Decomposition Product Carbon monoxide and carbon dioxide, oxides of silicon, smoke fumes, and unburned hydrocarbons. SAFETY DATA SHEET Page 6 of 8 Released: 2015-06-01 SC1 Version: 1.1 Revision Date: 2015-05-28 11. TOXICOLOGICAL INFORMATION Potential Health Hazards Eye Contact: Contact may be irritating to eyes. May cause redness, stinging, swelling and tearing. Skin Contact: May cause skin irritation with short-term exposure with redness, itching and burning of the skin. Prolonged and/or repeated contact may produce defatting and possible dermatitis. Inhalation: Mist or vapor can irritate the throat and lungs. High concentrations may cause nasal and respiratory irritation and central nervous system effects such as headache, dizziness and nausea. Intentional abuse may be harmful or fatal. Ingestion: This product has low oral toxicity. If swallowed, this material may cause irritation of the mouth, throat and esophagus. Swallowing may cause gastrointestinal irritation, nausea, vomiting, diarrhea, dizziness, drowsiness and other central nervous system effects. This product is an aspiration hazard. If swallowed, can enter the lungs and may cause chemical pneumonitis, severe lung damage and death. Chronic Effects: Prolonged or repeated skin contact may defeat the skin resulting in irritation and dermatitis. Carcinogen Status: None of the components are listed as a carcinogen or suspect carcinogen by IARC, NTP, ACGIH or OSHA. Reproductive Toxicity: None of the components is considered a reproductive hazard Numerical Measures of Toxicity: Naphtha (petroleum), light alkylate: Oral rat LD50: >5000 mg/kg, Inhalation rat LC50: >21 mg/L/4hr, Dermal rabbit LD50: >2000 mg/kg Liquefied Petroleum Gas: No toxicity data is available 12. ECOLOGICAL INFORMATION Ecotoxicity Naphtha (petroleum), light alkylate: 96 hr LL50 Rainbow trout: 18.4 mg/L, 48hr EL50 Daphnia magna: 2.4 mg/L, 21 days NOEC Daphnia magna: 0.17 mg/L, 21 days LOEC Daphnia magna: 0.32 mg/L This product is expected to be harmful to the aquatic environment with long-term adverse effects. Releases to the environment should be avoided. Biodegradation Bioaccumulation Mobility in soil Other adverse effects: Naphtha (petroleum), light alkylate: Expected to be inherently biodegradable. Bioaccumulation is not expected based on an assessment of the ingredients. No data available. None known. SAFETY DATA SHEET Page 7 of 8 Released: 2015-06-01 SC1 Version: 1.1 Revision Date: 2015-05-28 13. DISPOSAL CONSIDERATIONS Disposal If this product becomes a waste, it would be expected to meet the criteria of a RCRA ignitable hazardous waste (D001). However, it is the responsibility of the generator to determine at the time of disposal the proper classification and method of disposal. Do not puncture or incinerate containers, even empty. Dispose in accordance with federal, state, and local regulations. 14. TRANSPORT INFORMATION DOT IMDG ICAO UN Number Proper shipping name UN1950 UN1950 Aerosols Aerosols UN1950 Aerosols, flammable Hazard Class 2.1 2.1 Packing Group LTD QTY 2.1 Environmental Hazard Marine Pollutant (Hexane) Special precautions: None known. 15. REGULATORY INFORMATION CERCLA: This product is not subject to CERCLA reporting requirements, however, oil spills are reportable to the National Response Center under the Clean Water Act and many states have more stringent release reporting requirements. Report spills required under federal, state and local regulations. EPA SARA 302: This product does not contain chemicals regulated under SARA Section 302. EPA SARA 311/312 Hazard Classification: Acute Health, Fire Hazard, Sudden Release of Pressure EPA SARA 313: This product contains the following chemicals subject to SARA Title III Section 313 Reporting requirements: None VOC Regulations: This product complies with the consumer product VOC limits of CARB, the US EPA and states adopting the OTC VOC rules California Proposition 65: This product does not contain chemicals regulated under California Proposition 65. 16. OTHER INFORMATION NFPA Rating (NFPA 704): HMIS Rating: Health: 2 Health: 2 Fire: 4 Fire: 4 Instability: 0 Physical Hazard: 0 Date of Revision: May 28, 2015 Date of Previous Revision: August 2004 SC1 Released: 2015-06-01 Revision History: 5/28/15: Converted to GHS format. All section revised SAFETY DATA SHEET Page 8 of 8 Version: 1.1 Revision Date: 2015-05-28 The above information is based on the data of which we are aware and is believed to be correct as of the date hereof. Since this information may be applied under conditions beyond our control and with which we may be unfamiliar and since data made available subsequent to the date hereof may suggest modifications of the information, we do not assume any responsibility for the results of its use. This information is furnished upon condition that the person receiving it shall make his own determination of the suitability of the material for his particular purpose.Microsoft Word 2010 Microsoft Word 2010