Toyota Service and Repair Manuals. DTC & EWD - Free PDF's
Toyota Fuse and Relay Diagrams - Free PDF's
File Info : application/pdf, 16 Pages, 1.01MB
DocumentDocumentwww.car-inform.com Toyota Hilux Surf 3G fuse and relay Toyota Hilux Surf 3 generations were produced in 1995, 1996, 1997, 1998, 1999, 2000, 2001, 2002 with the body designation 180/185. During this time, the model was updated 2 times. Also known as Toyota 4Runner. In this publication, we will show the location of the electronic control units, a description of the fuses and relays of the Toyota Surf with box diagrams and photo examples of their execution. Highlight the cigarette lighter fuse. The arrangement of the boxes and the purpose of the elements in them may differ from that shown and depend on the year of manufacture and the level of equipment. Passenger compartment Location General layout of boxes in the cabin Left hand drive www.car-inform.com Right hand drive www.car-inform.com Assignment 1. Airbag control unit 2. All Wheel Drive Relay (ADD) 3. LHD: Fuel pump relay 4. Integrated relay 5. Fuse box 6. LHD: Relay for daytime running lights 7. Emission control unit (3RZ-F, 1RZ) Pre-heater timer (diesel) LHD: Engine control unit (2RZ-FE) RHD: Engine control unit (M / T) (3RZ-FE, 1RZ-E) RHD: Engine and gearbox control unit (A / T) (3RZ-FE, 1RZ-E) 8. Air conditioner amplifier 9. LHD: Differential lock control unit 10. ABS control unit 11. Deceleration sensor 12. RHD: Four-wheel drive control unit www.car-inform.com 13. RHD: Relay Box (Fuel Pump Relay (Circuit Opening)) 14. RHD: Antenna Relay 15. RHD: Australia: Distribution block Except Australia: Distribution connector 16. RHD: Light Relay (Dim-Dip) Fuse box Located at the bottom of the panel behind a protective cover. Photo example of execution Diagram www.car-inform.com Protected components R1 integrated relay 1 20A SEAT-HTR Heated seats 15A ACC Cigarette Lighter, Clock, Power Mirrors, Reversing Lights, Gear Selector 2 Lock 7.5A ECU-B Rear Fog Light, Airbag Indicator, Daytime Running Lights, Cruise 3 Control, ABS 20A 4WD Front differential shut-off system, four-wheel drive, rear differential 4 lock 5 10A TURN Direction indicators, hazard warning lights 10A GAUGE Instrument cluster, reversing lamps, cruise control, aerial, central 6 locking, gearbox control unit, starting system, charging system, heater control unit 7 15A ECU-IG ABS, transmission selector lock 8 20A WIPER Wiper and washer www.car-inform.com 10A IGN Charge Indicator, Airbags, Multiport Fuel Injection System / Sequential 9 Multiport Fuel Injection System 10 30A POWER Power windows, central locking The fuse number 2, 15A, is responsible for the cigarette lighter. Some relays are attached to the back of the unit. R1 Horn R2 Direction indicators (hazard warning lights) R3 Power relay (power windows, central locking) R4 Heated rear window Separately, in the relay box there is a fuel pump relay (petrol), an electromagnetic bypass valve (diesel) (until 08.1998) and a start-inhibit relay (until 08.1998) Engine compartment Location www.car-inform.com Layout of boxs under the hood Appointment 1. Fuse and Relay Box (Petrol, LHD Diesel) 2. Relay box No. 1 (LHD Diesel) 3. Relay box No. 2 4. Fuse and Relay Box (RHD Diesel) 5. Relay box # 1 (RHD) 6. Relay box # 3 (LHD) 7. Headlight wiper relay (LHD) 8. Relay box # 3 (RHD) 9. Relay box No. 4 (Israel) Fuse and relay box Type 1 Photo example www.car-inform.com Covery Diagram www.car-inform.com Designation 1 2 3 4 5 6 7 8 9 10 15A DEFOG Heated rear window 10A STOP Brake light 7,5A ALT-S Charging system 7,5A OBD Petrol: Diagnostic connector 20A AM2 Diesel: Multiport fuel injection system / sequential multiport fuel injection system 15A EFI Multiport fuel injection system / sequential multiport fuel injection system 15A HORN Sound signal, alarm 15A DOME Audio system, antenna, interior lighting, clock, ignition switch lighting, personal lighting, door lighting 20A AM2 Multiport fuel injection system / sequential multiport fuel injection system 10A TAIL Side light, license plate light, brake light, air conditioning, audio system, clock, cigarette lighter, instrument panel light www.car-inform.com 11 12 10A A.C Air conditioner 7,5A STA Multiport fuel injection system / sequential multiport fuel injection 13 system, starting system, instrument cluster 14 10A HEAD (RH) Right headlight 15 10A HEAD (LH) Left headlight 16 10A HEAD (LO RH) Low beam right 17 10A HEAD (LO LH) Low beam left 60A ABS Petrol: ABS 18 80A GLOW, ABS Diesel: Preheater, ABS 80A ALT 45A, 55A: Fuses: "ABS", "AM1", "STA", "ECU-B", "POWER", "RADIO", "ACC", "GAUGE", "TURN", "ECUI G "," WIPER "," 4WD "," HEATER "," AC "," TAIL "," PANEL "," STOP "," ALT-S " 100A ALT 70A: Fuses: "ABS", "AM1", "STA", "ECU-B", "POWER", "RADIO", "ACC", "GAUGE", "TURN", "ECUI G", "WIPER", "4WD", "HEATER", "AC", "TAIL", 19 "PANEL", "STOP", "ALT-S" 20 50A HEATER Air conditioner 40A AM1 Ignition switch, starting system, headlamp cleaner relay, fuel 21 heating, fuses: "ECU-B", "GAUGE" "POWER" 22 30A AM2 Ignition lock Relay R1 Dimmer R2 Side light (TAIL) R3 Headlights (HEAD) R4 Heater R5 Starter www.car-inform.com R6 Engine control unit (EFI) Type 2 Photo Covery www.car-inform.com Diagram www.car-inform.com Decoding 1 2 3 4 5 6 7 8 9 10 11 12 10A HEAD (RH) Right headlight 10A HEAD (LH) Left headlight 10A HEAD (RL) Low beam right 10A HEAD (LL) Low beam left 10A TAIL Side light, license plate light 7,5A STA Multiport fuel injection system / sequential multiport fuel injection system, starting system, instrument cluster 10A A / C Air Conditioning Not used Not used Not used Not used www.car-inform.com 13 Not used 14 15A HORN Sound signal 15A DOME Audio system, interior lighting, clock, personal lighting, door 15 lighting, daytime running lights, instrument cluster 16 7,5A OBD Diagnostic connector 15A EFI 2RZ-FE, 3RZ-FE: Multiport fuel injection system / sequential multiport fuel injection system 15A ECD 1KZ-TE, 5L-E: Multiport fuel injection system / sequential multiport fuel injection system 20A AM2 Diesel: Ignition switch, multiport fuel injection system / 17 sequential multiport fuel injection system 18 7,5A ALT - S Charging system 19 15A DEFOG Heated rear window 20 10A STOP Brake light 21 Not used 60A ABS Petrol: ABS 22 80A GLOW, ABS Diesel: Preheater, ABS 80A ALT 45A, 55A: Fuses: "ABS", "AM1", "STA", "ECU-B", "POWER", "RADIO", "ACC", "GAUGE", "TURN", "ECUI G "," WIPER "," 4WD "," HEATER "," AC "," TAIL "," PANEL "," STOP "," ALT-S " 100A ALT 70A: Fuses: "ABS", "AM1", "STA", "ECU-B", "POWER", "RADIO", "ACC", "GAUGE", "TURN", "ECUI G", "WIPER", "4WD", "HEATER", "AC", 23 "TAIL", "PANEL", "STOP", "ALT-S" 24 50A HEATER Heater, fuse: "A.C" 25 40A AM1 Starting system 26 30A CDS FAN Cooling fan 30A AM2 Ignition, Multiport fuel injection system / sequential multiport 27 fuel injection system www.car-inform.com 28 Relay R1 Gasoline: Starter R2 Heater R3 Cooling fan (CDS FAN) R4 Side light (TAIL) R5 R6 Engine control unit (EFI) R7 Engine control unit (ECD) R8 Headlights (HEAD) R9 Relay box No. 1 Dimmer R1 Starter (ST) R2 Glow plugs (SUB GLW) Relay box No. 2 R1 Dim-Dip No.3 R2 Dim-Dip No.2 www.car-inform.com Relay box No. 3 R1 Cooling fan (CDS FAN) R2 Cooling fan (CDS FAN NO.2) Relay box No. 4 R1 Motor ABS R2 ABS solenoid