Homepage - Polar Refrigeration
Instruction Manual for POLAR models including: DM075-A Display Fridge, DM075-A, Display Fridge, Fridge
30 janv. 2023 — Safety Instructions. • Position on a flat, stable surface. • A service agent/qualified technician should carry out installation and any repairs if required.
Polar G-Series Upright Display Fridge 368Ltr Black - GH427-A - Nisbets
File Info : application/pdf, 12 Pages, 1.19MB
DocumentDocumentDisplay fridge Instruction manual Model: DM075-A / DM076-A / GH426-A / GH427-A %."@%."@()"@()"@"@W@JOEC EN Telephone Helpline: 1300225960 Safety Instructions · Position on a flat, stable surface. · A service agent/qualified technician should carry out installation and any repairs if required. Do not remove any components or service panels on this product. · Consult Local and National Standards to comply with the following: - Health and Safety at Work Legislation - Fire Precautions - IEE Wiring Regulations - Building Regulations · DO NOT use jet/pressure washers to clean the appliance. · DO NOT use the appliance outside. · DO NOT use this appliance to store medical supplies. · DO NOT allow oil or fat to come into contact with the plastic components or door seal. Clean immediately if contact occurs. · DO NOT store products on top of the appliance. · Bottles that contain a high percentage of alcohol must be sealed and placed vertically in the refrigerator. · Always carry, store and handle the appliance in a vertical position and move by holding the base of the appliance. · Always switch off and disconnect the power supply to the unit before cleaning. · Keep all packaging away from children. Dispose of the packaging in accordance with the regulations of local authorities. · If the power cord is damaged, it must be replaced by a POLAR agent or a recommended qualified technician in order to avoid a hazard. · Children should be supervised to ensure that they do not play with the appliance. 2 %."@%."@()"@()"@"@W@JOEC Telephone Helpline: 1300225960 AENU · This appliance is not intended for use by persons (including children) with reduced physical, sensory or mental capabilities, or lack of experience or knowledge, unless they have been given supervision or instruction concerning the use of the appliance by a person responsible for their safety. · Polar recommend that this appliance should be periodically tested (at least annually) by a Competent Person. Testing should include, but not be limited to: Visual Inspection, Polarity Test, Earth Continuity, Insulation Continuity and Functional Testing. Caution: Risk of Fire · Do not store explosive substances such as aerosol cans with a flammable propellant in this appliance. Warning: Keep all ventilation openings clear of obstruction. Unit should not be boxed in without adequate ventilation. · Warning: Do not use mechanical devices or other means to accelerate the defrosting process, other than those recommended by the manufacturer. · Warning: Do not damage the refrigerant circuit. · Warning: Do not use electrical appliances inside the food storage compartments of the appliance. Introduction Please take a few moments to carefully read through this manual. Correct maintenance and operation of this machine will provide the best possible performance from your POLAR product. %."@%."@()"@()"@"@W@JOEC 3 EN Telephone Helpline: 1300225960 Pack Contents The following is included: POLAR Display fridge Keys x 2 Door handle assembly Shelves Instruction Manual POLAR prides itself on quality and service, ensuring that at the time of unpacking the contents are supplied fully functional and free of damage. Should you find any damage as a result of transit, please contact your POLAR dealer immediately. 2. Mount sleeve on the other end of screw. Tighten screws to fix the handle in place. Sleeve Installation Note: Not for use in vans or trailers, food trucks or similar vehicles. If the unit has not been stored or moved in an upright position, let it stand upright for approximately 12 hours before operation. If in doubt allow to stand. 1. Remove appliance from the packaging. Make sure that all protective plastic film and coatings are thoroughly removed from all surfaces. 2. To optimize performance and longevity, ensure a minimum clearance of 2.5cm is maintained between the unit and walls and other objects, with a minimum 20cm clearance on the top. NEVER LOCATE NEXT TO A HEAT SOURCE. Note: Before using the appliance for the first time, clean the shelves and interior with soapy water then dry well. 3. Set the brakes on the castors to keep the appliance in position. Reversing the door Depending on the location of the appliance, it may be necessary to change the direction the door opens by changing the side of the door handle. To reverse the door handle: 1. The door handle is on the left side originally. 2. Disassemble the front panel. Mounting the door handle 1. Pull the door gasket aside to expose the 2 predrilled holes. Insert the screws. Screw 3. Cut the slot on the front panel and install the hinge inside. Gasket 4 %."@%."@()"@()"@"@W@JOEC Telephone Helpline: 1300225960 AENU 4. Disassemble the right lower hinge and install it 6. Disassemble the right upper hinge. on the left lower side. 7. Install the left upper hinge. 5. Reverse the door. 8. At last, install the front panel. Now the door handle is on the right side. %."@%."@()"@()"@"@W@JOEC 5 EN Telephone Helpline: 1300225960 Operation Control Panel The control panel is located below the doors on the front of the appliance. · Do not obstruct the fans inside the appliance. · Avoid opening the doors for prolonged periods of time. Lock/Unlock the Doors · A lock is fitted to the door to ensure foodstuffs are kept secure within your POLAR appliance. · Use the keys provided to lock/unlock the door. To unlock / Lock the keyboard press and together for 3 seconds. Display will flash PON (unlocked) / POF (locked). Turn On 1. Close the door of the appliance. 2. Connect the appliance to a mains power supply. 3. Turn the light switches On [I] or Off [O] as desired. Set the Operating Temperature 1. Press the SET button. The display will flash. 2. Press the or buttons to display the required temperature. 3. Press the SET button to store the temperature. Manual Defrost Press and hold the defrost button "aux" for 2 seconds to begin a manual defrost. The defrost light illuminates. Storing Food To get the best results from your POLAR appliance, follow these instructions: · Only store foodstuffs in the appliance when it has reached the correct operating temperature. · Do not place uncovered items as below inside the appliance, as this can lead to a damaged and leaking evaporator, and thus void your warranty: hot food, hot liquids, acidic fluids, acidic products. · Wrap or cover food where possible. Cleaning, Care & Maintenance · Switch off and disconnect from the power supply before cleaning. · Clean the interior of the appliance as often as possible. · Do not use abrasive cleaning agents. These can leave harmful residues. · Clean the door seal with warm soapy water. · Always wipe dry after cleaning. · Do not allow water used in cleaning to run through the drain hole into the evaporation pan. · Take care when cleaning the rear of the appliance. Sharp edges can cut. Condensation and ice will form with frequent and prolonged opening of the doors. Operating outside of the recommend temperature range and placing next to a heat source will also increase the amount of ice and internal/external condensation. If external condensation occurs wipe the surface down with a cloth. Excessive ice will result in longer running times that will increase energy consumption and increase the deterioration of components. Replacing the Interior Lamp WARNING: Allow the lamp to cool before replacing. The lamp remains hot immediately after use. 1. Turn Off and disconnect the appliance from the mains power supply. 2. Unscrew the plastic lamp cover. 3. Remove the lamp by twisting it from the lamp sockets. 4. Insert the new lamp and replace the cover. 6 %."@%."@()"@()"@"@W@JOEC Telephone Helpline: 1300225960 AENU Cleaning the Condenser Periodically cleaning the condenser can extend the life of the appliance. POLAR recommend that a POLAR agent or qualified technician clean the condenser. Troubleshooting A qualified technician must carry out repairs if required. Fault Probable Cause Solution The appliance is not working The unit is not switched on Check the unit is plugged in correctly and switched on Plug or lead is damaged Replace Plug or lead Mains power supply fault Check mains power supply The appliance turns on, Too much ice on the condenser but the temperature is Condenser blocked with dust too high/low Doors are not shut properly Defrost the appliance Clean the condenser Check doors are shut and seals are not damaged Appliance is located near a heat source or air flow to the condenser is being interrupted Move the refrigerator to a more suitable location Ambient temperature is too high Increase ventilation or move appliance to a cooler position Unsuitable foodstuffs are being stored in the appliance Remove any excessive hot foodstuffs or blockages to the fan Appliance is overloaded Reduce the amount of food stored in the appliance The appliance is leaking water The appliance is not properly levelled Adjust the screw feet to level the appliance (if applicable) The discharge outlet is blocked Clear the discharge outlet Movement of water to the drain is Clear the floor of the appliance (if obstructed applicable) The water container is damaged Replace the water container The appliance is unusually loud Loose nut/screw The appliance has not been installed in a level or stable position Check and tighten all nuts and screws Check installation position and change if necessary The display lamp does Lamp needs replacing not illuminate Replace the lamp %."@%."@()"@()"@"@W@JOEC 7 EN Telephone Helpline: 1300225960 Technical Specifications Note: Due to our continuing program of research and development, the specifications herein may be subject to change without notice. Model Voltage DM075-A/GH426-A 220-240V~ DM076-A/GH427-A 50Hz Power 146W 146W Current 1A 1.3A Temp. Range 2°C ~ 8°C 2°C ~ 8°C Refrigerant Dimensions H x W x D mm R600a 1692 x 530 x 575 R600a 1982 x 620 x 570 Weight (kg) 124 134 Model DM075-A/GH426-A DM076-A/GH427-A Maximum load of each shelf 12.5kg 15kg Gross Capacity (L) 218 368 Net usable capacity (L) 180 225 Note: For optimal product performance and efficiency, please ensure to mind the net usable capacity (load limit) when filling. Electrical Wiring The plug is to be connected to a suitable mains socket. This appliance is wired as follows: · Live wire (coloured brown) to terminal marked L · Neutral wire (coloured blue) to terminal marked N · Earth wire (coloured green/yellow) to terminal marked E The appliances must be earthed. If in doubt consult a qualified electrician. Electrical isolation points must be kept clear of any obstructions. In the event of any emergency disconnection being required they must be readily accessible. Compliance The product must not be disposed of as household waste. To help prevent possible harm to human health and/or the environment, the product must be disposed of in an approved and environmentally safe recycling process. For further information on how to dispose of this product correctly, contact the product supplier, or the local authority responsible for waste disposal in your area. POLAR parts have undergone strict product testing in order to comply with regulatory standards and specifications set by international, independent, and federal authorities. POLAR products have been approved to carry the following symbol: All rights reserved. No part of these instructions may be produced or transmitted in any form or by any means, electronic, mechanical, photocopying, recording or otherwise, without the prior written permission of POLAR. Every effort is made to ensure all details are correct at the time of going to press, however, POLAR reserve the right to change specifications without notice. 8 %."@%."@()"@()"@"@W@JOEC DocuSign Envelope ID: E1BF2911-3323-41E5-8442-15C774182674 DECLARATION OF CONFORMITY · Conformiteitsverklaring · Déclaration de conformité · Konformitätserklärung · Dichiarazione di conformità · · Declaración de conformidad Equipment Type · Uitrustingstype · Type d'équipement · Gerätetyp · Tipo di apparecchiatura · Tipo de equipo 1. G-Series Upright Display Fridge White - 218Ltr 3. G-Series Upright Display Fridge Black - 218Ltr 2. G-Series Upright Display Fridge White - 350Ltr 4. G-Series Upright Display Fridge Black - 350Ltr Application of Territory Legislation & Council Directives(s) Toepassing van Europese Richtlijn(en) · Application de la/des directive(s) du Conseil · Anwendbare EU-Richtlinie(n) · Applicazione delle Direttive · Aplicación de la(s) directiva(s) del consejo Machinery Directive 2006/42/EC Supply of Machinery (Safety) Regulations 2008 (BS) EN 60335-1:2012 +A11:2014 +A13:2017 +A1:2019 +A14:2019 (BS) EN 60335-2-89:2010 +A1:2016 +A2:2017 (BS) EN 62233:2008 Electro-Magnetic Compatibility (EMC) Directive 2014/30/EU - recast of 2004/108/EC Electromagnetic Compatibility Regulations 2016 (S.I. 2016/1091) (BS) EN 55014-1:2017 (BS) EN 55014-2:2015 (BS) EN 61000-3-2:2014 (BS) EN 61000-3-3:2013 Model · Modèle · Modell · Modello · Modelo 1. DM075 (-E & -A) 3. GH426 (-E & -A) 2. DM076 (-E & -A) 4. GH427 (-E & -A) Electrical Safety IEC 60335-1:2010 +A1:2013 +A2:2016 IEC 60335-2-89:2010 +A1:2012 +A2:2015 EN 62233:2008 Electromagnetic Compatibility EN 55014-1:2017 EN 55014-2:2015 EN 61000-3-2:2014 EN 61000-3-3:2013 Ecodesign energy-related products Directive 2009/125/EC; Regulation (EU) 2019/2024 - Ecodesign direct sales refrigerators ISO 23953-2:2015 Restriction of Hazardous Substances Directive (RoHS) 2015/863 amending Annex II to Directive 2011/65/EU Restriction of the Use of Certain Hazardous Substances in Electrical and Electronic Equipment Regulations 2012 (S.I. 2012/3032) Producer Name · Naam fabrikant · Nom du producteur · Name des Herstellers · Nome del produttore · Nombre del fabricante Polar I, the undersigned, hereby declare that the equipment specified above conforms to the above Territory Legislation, Directive(s) and Standard(s). Ik, de ondergetekende, verklaar hierbij dat de hierboven gespecificeerde uitrusting goedgekeurd is volgens de bovenstaande Richtlijn(en) en Standaard(en). Je soussigné, confirme la conformité de l'équipement cité dans la présente à la / aux Directive(s) et Norme(s) ci-dessus Ich, der/die Unterzeichnende, erkläre hiermit, dass das oben angegebene Gerät der/den oben angeführten Richtlinie(n) und Norm(en) entspricht. Il sottoscritto dichiara che l'apparecchiatura di sopra specificata è conforme alle Direttive e agli Standard sopra riportati. El abajo firmante declara por la presente que el equipo arriba especificado está en conformidad con la(s) directiva(s) y estándar(es) arriba mencionadas. Date · Data · Date · Datum · Data · Fecha · Data Signature · Handtekening · Signature · Unterschrift Firma · Firma 18th October 2022 Full Name · Volledige naam · Nom et prénom · Vollständiger Name · Nome completo · Nombre completo Ashley Hooper Eoghan Donnellan Brendan Denmeade Position · Functie · Fonction · Position Technical & Quality · Qualifica · Posición Manager Commercial Manager/ Importer Commercial Manager/ Responsible Supplier Producer Address · Adres fabrikant · Adresse du producteur · Anschrift des Herstellers · Indirizzo del produttore · Dirección del fabricante Fourth Way, Avonmouth, Bristol, BS11 8TB United Kingdom Unit 9003, Blarney Business Park, Blarney, Co. Cork Ireland 15 Bagdally Road, Campbelltown NSW 2560 %."@%."@()"@()"@"@W@JOEC %."@%."@()"@()"@"@W@JOEC %."@%."@()"@()"@"@W@JOEC http://www.polar-refrigerator.com/ DM075-A_DM076-A_GH426-A_GH427-A_A5_v7_2023/01/30 %."@%."@()"@()"@"@W@JOEC