Lawn & Garden Equipment | Innovative Power Tools | WORX
Instruction Manual for WORX models including: WG185E, WG185E.X, WG185E.X Cordless Grass Trimmer, WG185E.X, Cordless Grass Trimmer, Grass Trimmer, Trimmer
7 cordless grass trimmer wg185e wg185e.x table of contents 1. product safty 2. component list 3. technical data 4. operating instructions 5. maintenance 6. environmental protection
NITRO 40V cordless grass trimmer 38cm - Tool Only | WORX
File Info : application/pdf, 16 Pages, 3.14MB
DocumentDocumentSAFETY AND OPERATING MANUAL ORIGINAL INSTRUCTIONS Cordless Grass Trimmer WG185E WG185E.X 10 9 12 11 3 8 2 1 4 5 6 7 A1 A2 B1 A3 B 1 2 C D1 D2 2 1 D3 D5 D4 100% 0% E 1 2 F G H I J1 J1 J2 22mm 2m K TABLE OF CONTENTS of the machine. 1. PRODUCT SAFTY b)Never allow children, 2. COMPONENT LIST persons with reduced 3. TECHNICAL DATA physical, sensory or mental 4. OPERATING INSTRUCTIONS 5. MAINTENANCE 6. ENVIRONMENTAL PROTECTION 7. DECLARATION OF CONFORMITY 8. PROBLEM SOLUTION capabilities or lack of experience and knowledge or people unfamiliar with these instructions to use the machine, local regulations 1.PRODUCT SAFETY GENERAL SAFETY WARNINGS WARNING Read all safety warnings and all instructions. Failure to follow the warnings and instructions may restrict the age of the operator. c) Keep in mind that the operator or user is responsible for accidents or hazards occurring to other people or their property. QE]VIWYPXMRIPIGXVMGWLSGOVI 2.Preparation and/or serious injury. a)Before use, always visually 7 Save all warnings and inspect the machine for instructions for future damaged, missing or reference. misplaced guards or shields. The appliance is only to b)Never operate the machine be used with the batteries while people, especially provided with the appliance. children, or pets are nearby. IMPORTANT READ CAREFULLY BEFORE USE KEEP FOR FUTURE REFERENCE Safe operating practices 1. Training a)Read the instructions carefully. Be familiar with the controls and the correct use 3. Operation a)Wear eye protection, long trousers and stout shoes at all times while operating the machine. b)Avoid using the machine in bad weather conditions especially when there is a risk of lightning. c) Use the machine only in HE]PMKLXSVKSSHEVXMGMEPPMKLX Cordless Grass Trimmer WG185E WG185E.X d)Never operate the machine from the machine and the with damaged guards or moving hazardous parts have shields or without guards or come to a complete stop. 8 shields in place. e)Switch on the motor only when the hands and feet are away from the cutting means. f) Always disconnect the machine from the power supply (e.g. remove the battery pack from the machine) 1)whenever the machine is left unattended; 2)before clearing a blockage; 3)before checking, cleaning or working on the machine; 4)after striking a foreign object; 5)whenever the machine starts vibrating abnormally. g)Take care against injury to 4.Maintenance and storage a)Disconnect the machine from the power supply (e.g. remove the battery pack from the machine) before carrying out maintenance or cleaning work. b)Use only the manufacturer's recommended replacement parts and accessories. c) Inspect and maintain the machine regularly. Have the machine repaired only by an authorized repairer. d)When not in use, store the machine out of the reach of children. feet and hands from the cutting means. h) Always ensure that the ventilation openings are kept BATTERY SAFETY SAFETY WARNINGS FOR BATTERY PACK clear of debris. a)Do not dismantle, open or M 2IZIVXQIXEPGYXXMRK shred cells or battery pack. elements. b)Do not short-circuit a j) Always be sure of your battery pack. Do not store footing on slopes. battery packs haphazardly k)Walk, never run. in a box or drawer where l) Not overreach and keep the they may short-circuit each balance at all times. other or be short-circuited m)Not to touch moving by conductive materials. hazardous parts before When battery pack is not removing the battery pack in use, keep it away from Cordless Grass Trimmer WG185E WG185E.X other metal objects, like of storage, it may be paper clips, coins, keys, necessary to charge and nails, screws or other small discharge the battery pack metal objects, that can several times to obtain make a connection from one maximum performance. terminal to another. Shorting k)Recharge only with the the battery terminals GLEVKIVWTIGMIHF];SV\ together may cause burns or Do not use any charger EVI SXLIVXLERXLEXWTIGMGEPP] c)Do not expose battery provided for use with the TEGOXSLIEXSVVI%ZSMH equipment. storage in direct sunlight. l) Do not use any battery pack d)Do not subject battery pack which is not designed for to mechanical shock. use with the equipment. e)In the event of battery m)Keep battery pack out of leaking, do not allow the the reach of children. liquid to come into contact n)Retain the original product with the skin or eyes. If literature for future contact has been made, reference. 9 wash the affected area with o)Remove the battery from copious amounts of water the equipment when not in and seek medical advice. use. f) Keep battery pack clean and p)Dispose of properly. dry. q)Do not use battery packs of g)Wipe the battery pack different manufacture, size terminals with a clean dry or type. cloth if they become dirty. r) Keep the battery away h)Battery pack needs to be from microwaves and high charged before use. Always pressure. refer to this instruction and use the correct charging procedure. i) Do not maintain battery pack on charge when not in use. j) After extended periods Cordless Grass Trimmer WG185E WG185E.X SYMBOL Read operator's manual Batteries may enter water cycle if disposed improperly, which can be hazardous for ecosystem. Do not dispose of waste batteries as unsorted municipal waste. 2.COMPONENT LIST Keep bystanders away Wear eye and ear protection 1. BATTERY PACK * 2. BATTERY INDICATOR LIGHT 3. LOCK-OFF BUTTON 4. VARIABLE-SPEED TRIGGER 5. ECO BUTTON 6. UPPER SHAFT 7. AUXILIARY HANDLE Do not expose to rain 8. LOWER SHAFT 9. SAFETY GUARD Waste electrical products must 10. LINE CUTTER not be disposed of with household waste. Please recycle where 11. TRIMMER HEAD (BUMP HEAD) 10 facilities exist. Check with your 12. RELEASE TAB local authorities or retailer for recycling advice. * Not all the accessories illustrated or described Li-Ion battery This product has are included in standard delivery. been marked with a symbol relating to `separate collection' 3.TECHNICAL DATA for all battery packs and battery pack. It will then be recycled or dismantled in order to reduce the impact on the environment. Type Designation: WG185E WG185E.X (1-designation of machinery, representative of Cordless Grass Trimmer) Battery packs can be hazardous for the environment and for human health since they contain hazardous substances. Voltage 40 V WG185E WG185E.X ** MAX (2x20V MAX) *** No-load speed 6000/min Make sure the battery is removed prior to changing accessories. Cutting Diameter for grass trimmer 38cm Trimming Do not burn Line Diameter Line Length Machine Weight (bare tool) 2.4mm Max 4m (Dual-Exit) 2.87kg ** X=1-999, A-Z, M1-M9 there are only used for different customers, there are no safe relevant Cordless Grass Trimmer WG185E WG185E.X changes between these models. ***Voltage measured without workload. Initial battery voltage reaches maximum of 20 volts. Nominal voltage is 18 volts. The tightness of the grip on the handles and if any anti vibration accessories are used. And the tool is being used as intended by its design and these instructions. SUGGESTED BATTERIES AND CHARGERS Category 20 V Battery 20 V Charger Model WA3014 WA3883 Capacity 4.0 Ah 4.0 A We recommend that you purchase your accessories listed in the above list from the same store that sold you the lawn trimmer. Refer to the accessory packaging for further details. Store personnel can assist you and offer advice. This tool may cause hand-arm vibration syndrome if its use is not adequately managed WARNING: To be accurate, an estimation of exposure level in the actual conditions of use should also take account of all parts of the operating cycle such as the times when the tool is switched off and when it is running idle but not actually doing the NSF8LMWQE]WMKRMGERXP]VIHYGIXLII\TSWYVIPIZIP over the total working period. Helping to minimise your vibration exposure risk. ALWAYS use sharp chisels, drills and blades Maintain this tool in accordance with these instructions and keep well lubricated (where appropriate) If the tool is to be used regularly then invest in anti vibration accessories. Plan your work schedule to spread any high vibration tool use across a number of days. NOISE INFORMATION 4.ASSEMBLY & OPERATION A weighted sound pressure KpA LpA = 78.7dB(A) 3.0 dB(A) Action Assembly Figure 11 A weighted sound power KwA LwA = 91.97 dB(A) 1.44dB(A) Assembling the Auxiliary Handle Assembling the pole See Fig. A1,A2,A3 See Fig. B Wear ear protection. VIBRATION INFORMATION Assembling the Safety Guard Insert the metal bracket into the slot on the safety guard, then secure the guard in place using the screw and hex key. See Fig. C Typical weighted vibration Uncertainty ah <1.5 m/s2 K = 1.5 m/s² The declared vibration total value may be used for comparing one tool with another, and may also be used in a preliminary assessment of exposure. WARNING: The vibration emission value during actual use of the power tool can differ from the declared value depending on the ways in which the tool is used dependant on the following examples and other variations on how the tool is used: How the tool is used and the materials being cut or drilled. The tool being in good condition and well maintained The use the correct accessory for the tool and ensuring it is sharp and in good condition. Installing and Removing the Battery Pack NOTE: · This machine will only run when 2 batteries are installed. It is recommended to use the same two batteries and charge the two batteries at the same time. · When two batteries are used with different amp hours or charge level, the machine will run to the lowest common denominator. · It is recommended that using 4.0Ah or above battery pack for better performance and longer run time. See Fig. D1, D2 Cordless Grass Trimmer WG185E WG185E.X Checking the battery charge condition NOTE: Fig. D3 only applies for the battery pack with battery indicator light. See Fig. D3 Charging the battery pack NOTE: · The batteries are shipped uncharged. Each battery must be JYPP]GLEVKIHFIJSVIXLIVWXYWI · Always fully charge the two batteries at same time. More details can be found in charger's manual. See Fig. D4 Battery power indicator on the machine See details in BATTERY STATUS section See Fig. D5 Operation To start WARNING! The cutting head continues to rotate after the trimmer has been switched off; wait until it has completely stopped then lay down See Fig. E the tool. 4VIWWXLIPSGOSJJFYXXSRVWX 12 then press the switch trigger to start the machine. ECO Speed For longer run time, press the ECO button and switch trigger, then your machine will operate at a low speed. See Fig. F Trimming See Fig. G Bump feed See Fig. H Assembling and removing the trimmer head Insert the hex key into the hole and rotate the trimmer head until it stops in a locked position. Then, rotate counterclockwise to remove it, and clockwise to assemble it. See Fig. I Winding the trimmer line NOTE: The spool must be wound while installed in the trimmer LIEH)\XIVREPP]VIPPIHWTSSPW inevitably leads to problems. See Fig. J1,J2 BATTERY STATUS (See Fig. D5) Before starting or after use, press the button beside the power indicator light on the machine to check the battery capacity. During operation, the battery capacity will be indicated automatically by the battery power indicator. The indicator constantly senses and displays the battery condition as follows. For the machine with 2 battery packs with different power, the power indicator light displays the battery condition with the lower one of the two batteries. Battery power indicator status Battery condition Five green lights ( ) are illuminated. The two batteries are in a highly charged condition. Two, three or four green lights are illuminated. The two batteries have a remaining charge. The more lights are illuminated, the more battery capacity. Only one green light At least one battery is almost ( ) is depleted and needs to be illuminated. charged. No light is illuminated. At least one battery is not fully installed or battery may be defective. Only one light is EWLMRKX[MGITIV cycle. At least one battery is over discharged (please refer to the battery charge condition), please recharge the two batteries at once before use again or storage. Only one light is At least one battery is hot, wait EWLMRKXLVIIXMQIW for them cool down before start per cycle. again. Only one light is EWLMRKJSYVXMQIW per cycle. The machine is over load. Raise the cutting height or push slowly. OPERATION INSTRUCTIONS WARNING! The charger and battery pack are specially designed to work together so do not attempt to use any other devices. Never insert or allow metallic objects into your charger or battery pack connections because of an electrical failure and hazard will occur. 1. Bump-line feed system (See Fig. H) The trimmer is equipped with a bump-line system. Just bump the trimmer head while the machine is running, new line will feed out. 2. Winding the trimmer line (WA0201)(See Fig. J1,J2) Insert the replacement line through the eyelet and feed it through the other side. Ensure both ends of Cordless Grass Trimmer WG185E WG185E.X the line are even on each end of the trimmer head (recommended 2m) and cut the line. Turn the dial clockwise to wind the line around the spool until about 19cm remains on either side. STORING YOUR GRASS TRIMMER Always remove the battery pack from your trimmer after use. To store your grass trimmer The trimmer is provided with a hanging slot for storing the trimmer on the wall. (See Fig. K) Store in a dry place where the trimmer and battery can be protected from damage. 5.MAINTENANCE Always remove the battery pack from your trimmer after use. Always check the product prior to being used for any damage. After use, disconnect the battery from the tool and check for damage. Your power tool requires no additional lubrication or maintenance. There are no user serviceable parts in your power tool. Never use water or chemical 13 cleaners to clean your power tool. Wipe clean with a dry cloth. Always store your power tool in a dry room temperature location. Keep the motor ventilation slots clean. Keep all working controls free of dust. 6. ENVIRONMENTAL PROTECTION Waste electrical products must not be disposed of with household waste. Please recycle where facilities exist. Check with your local authorities or retailer for recycling advice. Cordless Grass Trimmer WG185E WG185E.X 7.DECLARATION OF CONFORMITY We, Positec (UK & Ireland) Ltd. PO Box 6242, Newbury, RG14 9LT, UK Declare that the product Description Cordless Grass Trimmer Type WG185E WG185E.X (1-designation of machinery, representative of Cordless Grass Trimmer) Function cutting grass and similar soft vegetation and for trimming grass edges Complies with the following Directives: 2006/42/EC, 2014/30/EU, 2011/65/ EU&(EU)2015/863, 2000/14/EC amended by 2005/88/EC 2000/14/EC amended by 2005/88/EC: - Conformity Assessment Procedure as per Annex VI - Measured Sound Power Level 91.97 dB (A) - Declared Guaranteed Sound Power Level 94 dB(A) 8LIRSXMIHFSH]MRZSPZIH 2EQI-RXIVXIO(IYXWGLPERH+QF, RSXMIH 14 body 0905) Address: Stangenstraße 1, 70771 LEINFELDEN-ECHTERDINGEN Standards conform to EN 60335-1, EN 50636-2-91, EN 62233, EN ISO 3744, EN 55014-1, EN 55014-2 8LITIVWSREYXLSVM^IHXSGSQTMPIXLIXIGLRMGEPPI Name: Jim Kirkwood Address: Positec (UK & Ireland) Ltd., PO Box 6242, Newbury, RG14 9LT, UK 2022/06/21 Allen Ding (ITYX]'LMIJ)RKMRIIV8IWXMRK 'IVXMGEXMSR Positec Technology (China) Co., Ltd 18, Dongwang Road, Suzhou Industrial Park, Jiangsu 215123, P. R. China Cordless Grass Trimmer WG185E WG185E.X 8.TROUBLESHOOTING The following table gives problems and actions that you can perform if your machine does not operate correctly. Warning: Switch the machine off and remove the battery prior to any troubleshooting. Problems Possible Causes Corrective Action Trimmer fails to operate. Battery discharged. Battery too hot/cold. Motor is broken. Internal wiring of machine damaged. Recharge battery; also see the content in charger manual. Allow to cool/warm. Contact Service Agent. Contact Service Agent. Trimmer runs intermittently. Motor is broken. Battery not fully charged. On/Off switch defective. Contact Service Agent. Recharge battery. Contact Service Agent. Excessive vibrations/noise. Machine defective. Line spool is not wound well. Contact Service Agent. 6I[MRHXLIPMRI7II8SXWTSSPERH line assembly.'' Cutting time per battery charge too short. Battery has not been used for long period or only charged for short term. Grass too high. Battery defective. Fully charge battery; also see the content in charger manual. Cut in stages. Replace the battery. Machine does not cut. Line broken. Battery not fully charged. Motor is broken (speed is too low). Grass entangled around cutting head. Replace the line. Recharge battery; also see the content in charger manual Contact Service Agent. 15 Remove grass. Continuous lighting of the battery charge indicator. No charging procedure possible. Battery not (properly) inserted. Battery contacts contaminated. Battery defective. Properly insert battery into battery charger. Clean the battery contacts or replace the battery. Replace the battery. Battery charge indicator does not light up. Plug of battery charger not plugged in (properly). Socket outlet, mains cable or battery charger defective. Insert mains plug (fully) into the socket outlet. Check the mains voltage; have the battery charger checked by an authorized after-sales service agent. Cordless Grass Trimmer WG185E WG185E.X After-sales Service and Application At www.worx.com you can order spare parts or arrange the collection of a product in need of servicing or repair. Tel. Service: 0345 202 9679 E-Mail: customerservices@worxtools.com www.worx.com Copyright © 2022, Positec. All Rights Reserved.. AR01668900