[Atlas Metal Industries] 1069-1 | Commercial Kitchen Parts & Service
Subsidiary of Mercury Aircraft, Inc. 1135 N.W. 159th DR., MIAMI, FL 33169 PHONE (305) 625-2451, (800) 762-7565, FAX (305) 623-0475, E-mail: sales@atlasfoodserv.com PARTS LIST FOR RECESSED MECHANICAL COLD PANS RM & RML SERIES 1 3 4 2 5 6 12 7 11 RM-4 SHOWN 8 10 ITEM PART NUMBER NUMBER 1 S80103-0 S85008-0 2 86-3202 S83432-0 3 S83442-0 9 DESCRIPTION Separator Channel (RM) Separator Channel (RML) Perforated Snap- In Drain Pan Rail End RM'S (2 Req'd) Pan Rail Ends for RM-1, RML, (2 Req'd) S83438-0 Pan Rail Sides for RM-1 (2 Req'd) Pan Rail Sides for RM-2 (2 Req'd) S83440-0 Pan Rail Sides for RM-4 (4 Req'd) Pan Rail Sides for RM-6 (6 Req'd) S83439-0 Pan Rail Sides for RM-3 (2 Req'd) 4 S83441-0 Pan Rail Sides for RM-5 (4 Req'd) Pan Rail Sides for RML Only S83443-0 Pan Rail Sides for RML-2 (4 Req'd) Pan Rail Sides for RML-3 (6 Req'd) Pan Rail Sides for RML-4 (8 Req'd) ITEM NUMBER 5 6 7 8 9 10 11 12 13 14 PART NUMBER 7002-0+Model # 7020-0 1003-0 1069-1 2029-0 2029-5 2029-6 2029-7 3016-2 30-3130 49-1028 22-1397 2024-2 15 2027-0 DESCRIPTION Vinyl Bead Gasket Nylon Spacer Power Cord with Plug Switch with Light 1/5 H.P. Compressor 1/4 H.P. Compressor 1/3 H.P. Compressor 1/2 H.P. Compressor Stop Valve PVC Nipple Grommet Thermostat (Not Shown) Drier (Not Shown)) 0.031 Cap Tube (for 1/5 H.P) Comp. (Not Shown) 16 494-54(not shown 1/4 Expansion Valve RM-4-5-6 17 494-53(not shown 1/8 Expansion Valve RM-2-3 RECESSED MECHANICAL COLD PANS RM & RML SERIES INSTALLATION Provide the correct counter cut-out opening (see chart below) and drop in. The vinyl gasket assures complete seating. A non-toxic silicone seal may be used between the gasket and counter top (not required). Note: Units are supplied with a nipple and gate valve to be connected for draining. MODEL NUMBER CUT-OUT SIZE RM-1 RM-2 RM-3 RM-4 RM-5 RM-6 RML-2 RML-3 RML-4 24 1/2 X 16 1/2 24 1/2 X 30 1/4 24 1/2 X 44 24 1/2 X 57 3/4 24 1/2 X 71 1/2 24 1/2 X 85 1/4 16 1/2 X 46 1/2 16 1/2 X 68 1/4 16 1/2 X 90 --------------------------------------------------------------------------------------------------------------------------------------------The unit should be level for draining purposes. When installing unit in a counter, it is recommended that the operator side of the counter be completely open for air circulation. When this is not possible, such as in an island counter, it is recommended that two grill openings are provided approximately 18" x 18" of free air for intake and exhaust at the opposite ends of the counter. Also the counter must have an opening of approximately 24" x 14" to access the compressor for maintenance. Then the compressor can be reached by removing four (4) screws from the control and rear panels. The unit is supplied with a power cord and NEMA plug. Refer to the data plate on the compressor housing for the amperage and voltage information. Use a licensed electrician when installing power source. ------------------------------------------------------------------------------------------------------------------------------------------Note: see TABLE# 1 for BTU/HR and evaporator temperatures. ------------------------------------------------------------------------------------------------------------------------------------------- OPERATION This unit should be turned on one hour before serving and turned off after completing the serving period. The thermostat has been pre-set at the factory. All food products must be 34-35 degrees when placed in the unit. Food products must be 3 inches below the top of the unit. Note: The unit should not operate 24/7. ------------------------------------------------------------------------------------------------------------------------------------------- MAINTENANCE NEVER CLEAN PANS WITH A CHLORIDE BASED PRODUCT. CHLORIDES OR IMPROPER CLEANING COULD SCAR, MARK AND/OR CORRODE PANS. DO NOT USE STEEL WOOL OR ABRASIVE PRODUCTS. TO CLEAN USE SOAPY WARM WATER, RINSE THOROUGHLY TO REMOVE ALL RESIDUES. FAILURE TO MEET THESE CONDITIONS WILL VOID WARRANTY. CLEAN CONDENSER COIL REGULARLY.Acrobat Distiller 8.1.0 (Windows) Maricel Rodriguez