Sprinter.
Sprinter. Fuse Assignment Supplement ... Fuses/relays in the base of the driver's ... Always replace faulty fuses with speci ed.
É9075846909bËÍ 9075846909 Order no. T907 0369 13 Part no. 907 584 69 09 Edition 2021-06 Sprinter Fuse Assignment Supplement
File Info : application/pdf, 18 Pages, 601.56KB
DocumentDocumentÉ9075846909bËÍ 9075846909 Order no. T907 0369 13 Part no. 907 584 69 09 Edition 2021-06 Sprinter Fuse Assignment Supplement Publication details Internet Further information on Freightliner vans can be found at: https://www.freightlinersprinterusa.com Documentation team ©Mercedes-Benz AG: not to be reprinted, translated or otherwise reproduced, in whole or in part, without written permission from MercedesBenz AG. Vehicle manufacturer Mercedes-Benz AG Mercedesstraße 120 70372 Stuttgart Germany Vehicle dealers Daimler VANS USA, LLC One Mercedes-Benz Drive Sandy Springs, GA 30328 https://www.mbusa.com (USA only) https://www.freightlinersprinterusa.com Customer Assistance Center: 1-877-762-8267 Daimler VANS USA, LLC is a Daimler AG enterprise. As at 12.02.21 Symbols ....................................................... 2 Fuses and relays .......................................... 3 Notes on fuses ............................................. 3 Fuses and relays in the co-driver footwell .............................................................. 3 Fuses on the outside of the driver's seat base ............................................................ 8 Fuses/relays in the base of the driver's seat and in the battery box ......................... 11 Index ......................................................... 15 Contents 1 2 Symbols In this Supplement, you will nd the following symbols: & DANGER Danger due to not observing the warning notices Warning notices draw your attention to hazards that may endanger your health or life, or the health or life of others. # Observe the warning notices. + ENVIRONMENTAL NOTE Environmental damage due to failure to observe environmental notes Environmental notes include information on environmentally responsible behavior or environmentally responsible disposal. # Observe environmental notes. * NOTE Damage to property due to failure to observe notes on material damage Notes on material damage inform you of risks which may lead to your vehicle being damaged. # Observe notes on material damage. % These symbols indicate useful instructions or further information that could be helpful to you. # Instructions (/ page) Further information on a topic Display Display in the multifunction display/ media display * Indicates a cause Notes on fuses & WARNING Risk of accident and injury due to overloaded lines If you manipulate or bridge a faulty fuse or if you replace it with a fuse with a higher amperage, the electric line could be overloaded. This could result in a re. # Always replace faulty fuses with speci ed new fuses containing the correct amperage. * NOTE Damage or malfunctions caused by moisture Moisture may cause damage to the electrical system or cause it to malfunction. # When the fuse box is open, make sure that no moisture can enter the fuse box. # When closing the fuse box, make sure that the seal of the lid is positioned correctly on the fuse box. You can nd further information on fuses in the vehicle Operator's Manual. Fuses and relays in the co-driver footwell Fuse assignment Fuses and relays 3 4 Fuses and relays No. Consumer Fuse rat ing MF1 15-2 Engine control unit 5A 15-2 Common Powertrain Module 5 A (CPC) 15-2 ESP® control unit 5A 15-2 All-wheel drive control unit 5 A 15-2 Pre-installation for Onboard 5 A Logic Unit (OLU) control unit 15-2 Terminal 15, special signal, 5 A cockpit body manufacturer MF2 15-1 Feedback cable, terminal 15 5 A relay 15-1 Headlamp range control, hal- 5 A ogen headlamp 15-1 Tachograph TCO 5A 15-1 Active Brake Assist radar sen- 5 A sor 15-1 Deactivation of reverse warn- 5 A ing device, power take-o , working speed control 15-1 Device installation frame, 5A connector coupling MF3 30-T Multifunction camera 7.5 A 30-T Unassigned 30-T Connector coupling, device installation frame, roof 7.5 A 30-T Terminal 30T, special signal, 7.5 A cockpit body manufacturer 30-T Instrument cluster 7.5 A 30-T Device installation frame, cockpit 7.5 A S9 1 Unassigned No. Consumer Fuse rat ing 2 Common Powertrain Module 10 A (CPC) 3 Engine control unit OM642/ 10 A OM651/M274 Engine control unit OM654 5 A 4 Automatic transmission cen- 7.5 A tral oil pump 5 Common Powertrain Module 10 A (CPC) 6 Radiator fan control, terminal 5 A 87c S10 7 Automatic transmission intel- 30 A ligent servo module 8 Body controller 30 A 9 Body controller 30 A 10 Heating, SCR catalytic con- 30 A verter 11 Overhead control panel 10 A (standard) Overhead control panel, Cab 10 A Chassis Overhead control panel, 10 A delivery vehicle Overhead control panel (high) 15 A 12 Pump, SCR catalytic con- 15 A verter S11 13 Automatic transmission 60 A S12 14 ESP® valves (Premium), vehi- 40 A cles with electric parking brake ESP® valves (Standard) 25 A No. Consumer Fuse rat ing S13 16 ESP® pump 60 A S14 17 Body controller 30 A 18 Body controller 30 A 19 Terminal strip for body manu- 10 A facturer electrical connection 20 Co-driver door control unit 25 A 21 Driver's door control unit 25 A 22 Air suspension (LFA) control 10 A unit S15 23 Unassigned 24 USB port (cockpit), USB port 7.5 A (stowage compartment), converter socket 115 V/230 V 25 Cigarette lighter 15 A Socket, center console 15 A 26 Socket, instrument panel 15 A 27 Converter socket, 115 V/ 25 A 230 V 28 Radio pre-installation, cargo 7.5 A li gate, DSP connecting point, antenna voltage converter, 115 V/230 V converter socket for vehicles with auxiliary battery S16 30-1 Unassigned 30-2 Tachograph TCO 7.5 A 30-3 Central locking system 5A 30-4 Anti-the alarm system (ATA) 5 A 30-5 Unassigned Fuses and relays 5 No. Consumer Fuse rat ing 30-6 Electronic ignition lock con- 10 A trol unit 31-A Unassigned 31-B Starter power supply, relay 25 A S17 32 Unassigned S18 33 Voltage dip limiter (SEB) 5A S19 34 Electrics for body interior 10 A lighting S1 35 Ventilation blower regulator 30 A S2 36 Air conditioning control panel 5 A 37 Electric Steering Wheel Lock- 5 A ing (ESTL) 38 Steering Column Switch 10 A Module (SCSM) 39 Digital signal processor pre- 10 A installation 40 Rotating beacon 5A 41 Radio multimedia system/ 25 A radio pre-installation S3 42 Unassigned S4 43 Unassigned S5 44 Switch panel, multimedia sys- 5 A tem 45 Mobile phone cradle (WMI) 5 A 6 Fuses and relays No. Consumer Fuse rat ing 46 Multimedia connection unit 7.5 A (MMI) 47 Hermes (LTE communication 5 A module) 48 Telestart stationary heating 5 A 49 Central display 5A S6 50 Additional headlamp, le 5A (platform body manufacturer) 51 Additional headlamp, right 5A (platform body manufacturer) Switch clock for the auxiliary 5 A heating air, terminal 15 relay 52 Control unit, airbag 7.5 A 53 Diagnostics 5A 54 Relay supply 5A 55 Engine connecting point (die- 7.5 A sel), engine control unit (OM651/OM642/M274) S7 56 Control unit (OM654) 15 A 57 Soot particulate sensor, NOX 15 A sensor, main catalytic converter (OM654) Soot particulate sensor 10 A 58 Engine, exhaust gas recircula- 10 A tion (EGR) (OM642/OM651) Engine (M274/OM654) 15 A 59 NOX sensor before/a er cat- 10 A alytic converter 60 Lambda sensor 7.5 A Coolant pump (OM654) 15 A 61 Engine (M274/OM651) 10 A Engine (OM642) 7.5 A No. Consumer Fuse rat ing Engine (OM654) 5A H2 62 Engine (M274/OM654) 15 A Engine (OM651/OM642) 20 A 63 Engine (M274) 20 A Engine (OM651/OM642/ 25 A OM654) S8 64 Body controller 30 A 65 Body controller 30 A 66 Automatic transmission auxil- 15 A iary oil pump 67 Control unit for fuel measure- 25 A ment (FSCM) 68 LED headlamp, right 15 A 69 LED headlamp, le 15 A H2 70 Windshield wipers 30 A Relays in the co-driver footwell Fuses and relays 7 No. Designation Permissible current intensity R1 Reserve 30 A R2 Terminal 87, engine 50 A R3 Terminal 87, Common Pow- 30 A ertrain Module CPC R4 Terminal 15 40 A R5 Windshield wipers on/o 40 A R6 Reserve 40 A R7 Windshield wipers fast/ 40 A slow R8 Terminal 50, starter 40 A R9 Terminal 15R (vehicles with- 50 A out auxiliary battery) R10 Starter power supply, relay 30 A R11 Terminal 15R (vehicles with 50 A auxiliary battery) 8 Fuses and relays Fuses on the outside of the driver's seat base Fuse assignment Fuse block F55/1 No. Consumer Fuse rat ing 1 Additional turn signal lamp 10 A Roof ventilator 15 A 2 Rear window wiper, right 15 A 3 All-wheel drive control unit 30 A 4MATIC all-wheel drive control 30 A unit 4 Parking Package 5A Rear view camera 5 Driver seat adjustment control 25 A unit Seat heating control unit, driver/co-driver with individual seat 6 Driver lumbar support 10 A Co-driver lumbar support 7 Co-driver seat adjustment 25 A control unit No. Consumer Fuse rat ing Seat heating control unit, codriver bench seat 8 Tire pressure monitoring sys- 5 A tem Motion detector 9 Rear blower 25 A Fuse block F55/2 No. Consumer Fuse rat ing 10 Trailer coupling control unit, 25 A right 11 Trailer coupling control unit 15 A (socket) 12 Trailer coupling control unit, 25 A le 13 Trailer coupling control unit 15 A (charging cable) No. Consumer Fuse rat ing 14 Parameterizable special mod- 25 A ule control unit 15 Parameterizable special mod- 25 A ule control unit 16 Terminal 30, terminal strip for 25 A body manufacturer's electrical connection 17 Hot-water auxiliary heater 20 A 18 Terminal 30T for terminal 15 5 A relay Fuse block F55/3 No. Consumer 19 Rear window heater, le Additional caravanning unit (PWM 1) 20 Rear window heater, right Additional caravanning unit (PWM 2) 21 Rear window heater relay Additional caravanning unit control unit 22 Trailer brake booster 23 Cargo li gate/dumper vehicle (pre-installation) Roof ventilator 24 Terminal strip for electrical connection (body manufacturer) 25 Rear view camera/rear view camera pre-installation Rear view camera display, inside rearview mirror 26 Hot-air auxiliary heater Fuse rat ing 15 A 25 A 15 A 25 A 30 A 5A 30 A 7.5 A 5A 15 A 5A 15 A Fuses and relays 9 No. Consumer Fuse rat ing Supply, terminal 15, auxiliary battery relay Central locking system, deliv- 20 A ery vehicle 27 Auxiliary battery voltage 5A measurement Fuse block F55/4 No. Consumer Fuse rat ing 28 Sliding door, le 15 A Electric sliding door, le 30 A Intermediate door, delivery 5A vehicle Speed delivery door 30 A 29 Sliding door, right 15 A Electric sliding door, right 30 A Reading lamp, delivery vehicle 5 A Speed delivery door 30 A 30 Antenna switch box 5A Interior lighting, body, delivery vehicle 31 Automatic transmission, Ultra- 10 A cap 32 Automatic transmission, 7G- 10 A TRONIC PLUS 33 Pre-installation for Onboard 30 A Logic Unit (OLU) 34 Pre-installation, siren 15 A Pre-installation for camper van 30 A OLU Connect Unit 5A 35 Rotating beacon with siren 15 A Pre-installation for camper van 30 A OLU Compute Unit 10 A 10 Fuses and relays No. Consumer Fuse rat ing 36 Pre-installation for camper van 30 A OLU Compute Unit 10 A Fuse block F55/5 No. Consumer Fuse rat ing 37 Electrical step, le 10 A 38 Electrical step, right 10 A 39 Warning buzzer, electrical 5A steps 40 Unassigned ATO 41 Air spring 5A 42 Retarder 5A 43 Socket, cab 15 A 44 Socket, D-pillar, le 15 A 45 Socket, D-pillar, right 15 A Fuse block F55/6 No. Consumer 51 USB port, side wall, front le USB port, side wall, front le (with sliding door, le ) 52 USB port, side wall, front right USB port, side wall, front right (with sliding door, right) 53 USB port, side wall, rear le (bus) USB port, side wall, rear le (Passenger Van) 54 USB port, side wall, rear right (bus) USB port, side wall, rear right (Passenger Van) Fuse rat ing 7.5 A 5A 7.5 A 5A 7.5 A 5A 7.5 A 5A Fuses and relays 11 Fuses/relays in the base of the driver's seat and in the battery box Fuse assignment Additional fuses and relays etc. are located in the seat base of the driver's seat: R For the windshield heater R For other major assemblies, such as power- steering pumps, auxiliary battery, battery cuto relays and PTC heater boosters R From the body manufacturers for retarders, cargo li gate, hydraulic pump and dumper vehicle % Always have the fuses and relays in the seat base replaced at a uali ed specialist workshop. Fuse block F150/1 (MFB-1) in the battery box No. Consumer Fuse rat ing 1 Battery sensor 2 Unassigned MIDI 3 Main fuse box (MFB-2) Busbar 4 Power Distribution Center, ter- 50 A minal 30 (F30-1 F30-6) 5 PTC heater booster 125 A Fuse block F150/4 (MFB-2) 12 Fuses and relays No. Consumer Fuse rat ing 1 Terminal 30T, fuse box, seat 125 A base of driver's seat (fuse block F55/1 - F55/6) 2 Electric steering 125 A 3 Alternator 300 A Alternator (code M60 or M61) 400 A 4 Unassigned 5 Power Distribution Center (PDC) 175 A 6 Glow output stage (GZE) 80 A 7 Mono fan, air conditioning 40 A system Duo fan, air conditioning sys- 80 A tem Fan, radiator OM654/M274 100 A 8 Camper van (fuse block F55/4) 100 A 9 Camper van (code E1R) 150 A Camper van (code E1Y) 80 A 10 High performance roof-moun- 100 A ted air conditioning system (code HK4) Enhanced roof-mounted air 50 A conditioning system (code H08) Basic roof-mounted air condi- 25 A tioning system (code HH7) Camper van (without roof- 80 A mounted air conditioning sys- tem) 11 Auxiliary battery/battery cut- 150 A o relay Retarder without auxiliary bat- 100 A tery No. Consumer Fuse rat ing 12 Air suspension/camper van 40 A (without air suspension) 13 Windshield heater 80 A Fuse block F150/5 (MFB-ZB) No. Consumer 1 Retarder 2 Cargo li gate/dumper vehicle (pre-installation) 3 Auxiliary battery 4 Battery cuto relay 5 DC/AC converter sockets with auxiliary battery 6 Hot-air auxiliary heater with auxiliary battery Hot air auxiliary heater, supply for additional caravanning unit with auxiliary battery Parcel service delivery vehicle Fuse rat ing 100 A 250 A 150 A 60 A 25 A 80 A 40 A Individual fuses F59/1 and F59/2 No. Consumer Fuse rat ing 1 Windshield heater, le 40 A 2 Windshield heater, right 40 A Relay holder K100 Fuses and relays 13 Right-hand-drive vehicles No. Designation Supplementary relay, bottom 1 Windshield heater 2 Terminal 15 3 Rear window heater 4 Sockets, rear compartment 5 Unassigned 6 Unassigned 7 Unassigned Supplementary relay, top 8 Unassigned 9 Unassigned 10 Unassigned 11 Unassigned 12 Unassigned 13 Unassigned 14 Unassigned Mini-relay No. Designation 15 Rear window wiper, right 16 Terminal strip body manufacturer 17 Switch, reverse warning device 18 Roof ventilator Interior lighting 19 Auxiliary oil pump 20 Electrical step, right 1 21 Electrical step, right 2 22 Electrical step, le 1 23 Electrical step, le 2 24 Siren Reading lamp, parcel service delivery vehicle 25 Rotating beacon with siren 26 Cargo li gate Terminal 15 on auxiliary battery Relay holder K57/2 Auxiliary battery relay 14 Fuses and relays Le -hand-drive vehicles No. Designation Supplementary relay, bottom 1 Unassigned 2 Unassigned 3 Unassigned 4 Unassigned 5 Unassigned 6 Unassigned 7 Unassigned Supplementary relay, top 8 Windshield heater 9 Terminal 15 10 Rear window heater 11 Sockets, rear compartment 12 Unassigned 13 Unassigned 14 Unassigned Mini-relay 15 Rear window wiper, right 16 Terminal strip body manufacturer 17 Switch, reverse warning device 18 Roof ventilator Interior lighting 19 Auxiliary oil pump 20 Electrical step, right 1 21 Electrical step, right 2 22 Electrical step, le 1 23 Electrical step, le 2 24 Siren Reading lamp, parcel service delivery vehicle 25 Rotating beacon with siren No. Designation 26 Cargo li gate Terminal 15 on auxiliary battery Relay holder K57/2 Auxiliary battery relay F Fuses Notes on fuses........................................ 3 Fuses on the outside of the driver's seat base Fuse assignment..................................... 8 Fuses/relays in the base of the driver's seat and in the battery box Fuse assignment................................... 11 Relay holder K100................................. 13 Fuses/relays in the front-passenger footwell Fuse allocation........................................ 3 Relay assignment.................................... 7 Index 15AH XSL Formatter V6.4 MR1 for Windows (x64) : 6.4.3.27525 (2017/01/23 10:11JST) OneVision PDFengine (Windows 64bit Build 25.092.S)