T101R Instructions ?sku=897-T101R MODEL: T101R
LR3730
24 HR DIAL TIME SWITCH (SPST)
IN TYPE 3R DUSTPROOF RAINPROOF ENCLOSURE SUITABLE FOR POOL
EQUIPMENT CONTROL IF INSTALLED 5FT. OR MORE FROM EDGE OF POOL.
40 AMP. RESISTIVE, INDUCTIVE, TUNGSTEN OR 1000 VA PILOT DUTY 120/208/240 VOLT AC; 2 HP (24 FLA) - 120V AC; 5 HP (28 FLA) - 240V AC
CLOCK MOTOR: 110-125 VOLTS - 60 HZ.
CLOCK MOTOR VOLTAGE AND CYCLE MUST BE AS SPECIFIED. TO ORDER REPLACEMENT, INDICATE ART NO. (WG--) ON MOTOR COVER.
TIME DIAL
TIME POINTER
OFF TRIPPER MANUAL LEVER
ON TRIPPER
WIRING DIAGRAM
GRD.
CLOCK MOTOR
A1 2
120V SUPPLY
NEUT.
TO
LINE
LOAD
GROUND
WIRING INSTRUCTIONS: To wire switch follow diagram above. Use solid or stranded COPPER only wire with insulation to suit installation. See gauge selection table for normal service applications.To make power connections remove 1/2 inch of insulation from wire ends. Insert bare ends of wire under the pressure plate of terminals. Use 3/16 or larger screwdriver to tighten terminal screws firmly. (25 lb-in minimum). REPLACE INSULATOR BEFORE TURNING ON ELECTRICITY.
MINIMUM COPPER WIRE SIZE (AWG)
14 12 10 8
MAX. LOAD (AMP)
MIN. INSULATION TEMP (°C)
15
60
20
60
30
60
40
75
75°C INSULATION MAX. MOTOR LOAD (HP)
SINGLE PHASE
3 PHASE
120 V.
1/2 1 2 -
240 V.
2 2 1/2
3 5
208 V. 240 V.
N/A N/A
PRESSURE PLATE
TERMINAL SCREW
MAKE SURE WIRE INSULATION CLEARS PRESSURE PLATE
PROGRAMMING INSTRUCTIONS 1. TO SET "ON" AND "OFF" TIMES: Hold trippers against edge
of CLOCK-DIAL, pointing to time (AM or PM) when ON and OFF operations are desired, tighten tripper screws firmly. For additional tripper pairs on CLOCK-DIAL order 156T1978A. 2. TO SET TIME-OF-DAY: Pull CLOCK-DIAL outward. Turn in either direction and align the exact time-of-day on the CLOCKDIAL (the time now, when switch is being put into operation) to the pointer. DO NOT MOVE POINTER. OPERATING INSTRUCTIONS · TO OPERATE SWITCH MANUALLY: Move MANUAL LEVER below CLOCK-DIAL left or right as indicated by arrows. This will not effect next operation. · IN CASE OF POWER FAILURE, reset CLOCK-DIAL to proper time-of-day. See programming instructions.
INTERMATIC INCORPORATED
158TS10914 SPRING GROVE, ILLINOIS 60081-9698
Adobe InDesign CS3 (5.0.4) Adobe PDF Library 8.0