Trufrost – The new vocabulary of cooling & foodservice
User Manual for TRUFROSt and BUTLER models including: S 900, S 903 New, PS 200 New, PS 300 New, S 900 Professional Sala Dettes, S 900, Professional Sala Dettes, Sala Dettes, Dettes
S 903 – Trufrost
File Info : application/pdf, 8 Pages, 564.89KB
DocumentDocumentUSERMANUAL Professional Saladettes: S 900 S 903 (New) PS 200 (New) PS 300 (New) User Manual Table of Contents Safety Tip .......................................................................................... 3 Introduction ....................................................................................... 4 Pack Contents ................................................................................... 4 Installation ......................................................................................... 4 Fitting the Shelves ............................................................................ 5 Operation ........................................................................................... 5 Storing Food ..................................................................................... 5 Turn on .............................................................................................. 5 Open/Close the Lid ........................................................................... 5 Manual Defrost .................................................................................. 6 Cleaning, Care & Maintenance ......................................................... 6 Cleaning the Condenser ................................................................... 6 Disposal ............................................................................................. 6 Compliance ....................................................................................... 7 Troubleshooting ............................................................................... 8 2 User Manual Safety Tips · Position on a flat and stable surface. · A service agent/qualified technician should carry out installation and any repairs if required. Do not remove any components or service panels on this product. · Consult Local and National Standards to comply with the following: o Health and Safety at Work Legislation o BS EN Codes of Practice o Fire Precautions o IEE Wiring Regulations o Building Regulations · DO NOT use jet/pressure washers to clean the appliance. · DO NOT use the appliance outside. · DO NOT use this appliance to store medical supplies. · DO NOT use electrical appliances inside this product (e.g. heaters, ice-cream makers etc.) · DO NOT allow oil or fat to come into contact with the plastic components or door seal. Clean immediately if contact occurs. · DO NOT place more than 30kg load on each shelf. · Bottles which contain a high percentage of alcohol must be sealed and placed vertically in the appliance. · Always carry, store and handle the appliance in a vertical position and move by holding the base of the appliance. · Always switch off and disconnect the power supply to the unit before cleaning. · Keep all packaging away from children. Dispose of the packaging in accordance with the regulations of local authorities. · If the power cord is damaged, it must be replaced by an agent or a recommended qualified technician in order to avoid hazard. · Do not store explosive substances such as aerosol cans with a flammable propellant in this appliance. · This appliance can be used by children aged from 8 years and above and persons with reduced physical sensory or mental capabilities or lack of experience and knowledge if they have been given supervision or instruction concerning use of the appliance in a safe way and understand the hazards involved. Children shall not play with the appliance. Cleaning and user maintenance shall not be made by children without supervision. The instructions concerning persons (including children) with reduced physical, sensory or mental capabilities or lack of experience and knowledge playing with the appliance are not required. 3 User Manual WARNING: Keep ventilation openings, in the appliance enclosure or in the built-in structure, clear of obstruction. Do not use mechanical devices or other means to accelerate the defrosting process, other than those recommended by the manufacturer. Do not damage the appliance circuit. Do not use electrical appliances inside the food storage compartments of the appliance, unless they are of the type recommended by the manufacturer. Introduction Please take a few moments to carefully read through this manual, correct maintenance and operation of this machine will provide the best possible performance from your product. Pack Contents The following is included: · Refrigerator · Shelves · Shelf guides · Instruction manual · Gastronorm Adaptor Bars We pride ourselves on quality and service, ensuring that at the time of packaging the contents are supplied fully functional and free of damage. Should you find any damage as result of transit, please contact your dealer immediately. Installation Note: if the appliance has not been stored or moved in an upright position, let it stand upright for approximately 12 hours before operation. If in doubt allow the appliance to stand. 1. Remove the appliance from the packaging. Make sure that all protective plastic film and coatings ate thoroughly removed from all surfaces. 2. Maintain a distance of 20cm (7 inches) between the unit and walls or other objects for ventilation. Increase this distance id the obstacle is a heat source. Note: Before using the appliance for the first time, clean the shelves and interior with soapy water. 3. Set the brakes on the castors to keep the appliance in position OR level the appliance by adjusting the screw feet. 4 User Manual Note: The R600a and R290 refrigerant used by this appliance. Fitting the Shelves 1. Place one set of shelf guides on either side of the cabinet at the desired height. 2. Slide the shelf into place. 3. Repeat for the remaining shelves. 4. The shelf supports up to 30kg. Note: this is vital for ensuring correct drainage of condensation Operation Storing Food To get the best results from your appliance, follow these instructions: · Only store foodstuffs in the appliance when it had reached the correct operating temperature. · Do not place uncovered hot food or liquid inside the appliance. · Wrap or cover food where possible. · Do not obstruct the fans where possible · Do not obstruct the fans inside the appliance. · Avoid opening the doors for prolonged periods of time. · Foodstuffs should be 30cm away from the back of the appliance. · Do not place constituents of foods (e.g. acid, alkali or salt) inside the appliance. Turn on 1. Close the door(s) of the appliance. 2. Ensure the power switch is set to [ON] and turn on at the socket. 3. Switch on the Power [I]. the current temperature within the appliance is displayed. Open/Close the Lid The lid of the 900 and 903 Saladette Counter is multi-positional: 1. With the lid closed, slide the panel back into the half open position. This allows partial access to the gastronorm trays. 2. Lift the lid up and back so the highe settles into the support slot. 3. Lift the lid up and completely back so the gastronorm trays are completely exposed. 5 User Manual WARNING: The sliding lid does not have a locking mechanism. Always make sure that the lid is in the "half-open" position. before opening. Manual Defrost The appliance will automatically run a defrost cycle every six hours. Note: The cycle starts from the time the appliance is initially powered up. To manually defrost the appliance: 1. Press and hold the DEFROST button for 5 seconds. 2. The defrost cycle will start immediately and the Defrost LED illuminates. The defrost will last a maximum of 30 minutes. Note: Starting a manual defrost also resets the automatic defrost timer. The next automatic defrost will start six hours after the manual defrost has finished. 3. Waste water is collected in the waste water tray. Cleaning, Care & Maintenance · Switch off and disconnect from the power supply before cleaning. · Clean the interior of the appliance as often as possible. · Do not use abrasive cleaning agents. These can leave harmful residues. · Clean the door seal with water only. · Always wipe dry after cleaning. · Do not allow water used in cleaning to run through the drain hole into the evaporation pan. · Take care when cleaning the rear of the appliance, sharp edges can cut. · An agent or qualified technician must carry out repairs if required. Cleaning the Condenser Periodically cleaning the condenser can extend the life of the appliance. We recommend that out agent or qualified technician clean the condenser. Disposal EU regulations require refrigeration product to be disposed of by specialist companies who remove or recycle all gasses, metal and plastic components. Consult your local waste collection authority regrading disposal of your appliance. Local authorities are not obliged to dispose of commercial refrigeration equipment but may be able to offer advice on how to dispose of the equipment locally 6 User Manual Compliance Parts have undergone strict product testing in order to comply with regulatory standards and specifications set by international, independent, and federal authorities. Products have been approved to carry the following symbol: Disposal of packaging All packaging materials should be disposed of in an environmentally friendly way. The cardboard may be used as scrap paper. The protective foil and the foam cushions are CFC-free. Do not allow children to play with the packaging and destroy plastic bags safely. You can break or cut the cardboard into smaller pieces and give to a waste paper disposal service. Environment protection Discarded electric appliances are recyclable and should not be discarded in the domestic waste! Please actively support us in conserving resources and protecting the environment by returning this appliance to the collection centers (if available). IN CASE THE SUPPLY CABLE IS DAMAGED, THE MANUFACTURER OR THE AFTER-SALES SERVICE, OR QUALIFIED TECHNICIAN SHALL REPLACE IT, IN ORDER TO PREVENT ANY POSSIBLE RISK. THE LAMP REPAIR AND REPLACEMENT SHALL BE CARRIED OUT BY QUALIFIED TECHNICIANS, WITH POWER SUPPLY DISCONNECTED. REPLACE WITH IDENTICAL LAMPS. ONLY QUALIFIED TECHNICIANS SHALL CARRY OUT THE EXTRAORDINARY MAINTENANCE INTERVENTIONS. 7 User Manual Troubleshooting If your appliance develops a fault, please check the following table before making a call to your retailer. Fault Probable Cause Action The appliance is not working The unit is not switched on Plug and lead are damaged Fuse in the plug has blown Check the unit is plugged in correctly and switched on Call your agent or qualified Technician Replace the fuse Power supply Check power supply Internal wiring fault Call your agent or qualified Technician Too much ice on the Defrost the appliance evaporator Condenser blocked with dust Call your agent or qualified Technician The appliance turns on, but the temperature is too high/low The appliance is leaking water Doors are not shut properly Appliance is located near a heat source or air flow to the condenser is being interrupted Ambient temperature is too high Unsuitable foodstuffs are being stored in the appliance Appliance is overloaded The appliance is not properly levelled The discharge outlet is blocked Movement of water to drain is obstructed The water container is damaged The drip tray is overflowing Check doors are shut and seals are not damaged Move the appliance to a more suitable location Increase ventilation or move appliance to a cooler position Remove ant excessive hot foodstuff or blockages to the fan Reduce the amount of food stored in the appliance Adjust the screw feet to level the appliance (if applicable) Clear the discharge outlet Clear the floor of the appliance (if applicable) Call your agent or qualified Technician Empty the drip tray (if applicable) The appliance is unusually loud Loose nut/screw The appliance has not been installed in a level or stable position Check and tighten all nuts and screws Check installation position and change is necessary Marketed globally by: TRUFROST AND BUTLER PRIVATE LIMITED 1215, 12th Floor, Tower B, Emaar Digital Greens, Golf Course Extn. Road, Sector 61, Gurugram 122011 (India) T. 91-7303166766 info@trufrost.com www.trufrost.com 8