Introduction
This manual provides comprehensive instructions for the proper installation and care of your Remo 18-4201-70 Tubano Replacement Foot. This component is designed to restore stability to your Remo Tubano drum, specifically recommended for newer models of the 50 or 100 series Tubanos. Adhering to these instructions will ensure correct fitment and prolong the life of your drum's support system.
Package Contents
Upon opening your package, please verify that all the following items are included:
- 1 x Remo Tubano Replacement Foot (Model 18-4201-70)
- 2 x Mounting Screws
- 1 x Instruction Sheet (this document)
Figure 1: The Remo 18-4201-70 Tubano Replacement Foot, a black, curved piece with two screw holes, as supplied in the package.
Tools Required (Not Included)
To successfully install the replacement foot, you will need the following tools:
- Rubbing Alcohol (for cleaning the surface)
- Drill
- 3/32" Drill Bit
Installation Instructions
- Prepare the Surface: Carefully remove any remaining pieces of the old foot and screws from your Tubano drum. Clean the area where the new foot will be installed using rubbing alcohol to ensure a clean, dry surface.
- Position the New Foot: Align the new Remo 18-4201-70 Tubano Replacement Foot with the existing screw holes on the drum. Ensure the foot sits flush against the drum's base.
- Drill Pilot Holes (if necessary): If the existing screw holes are damaged or if you are installing in a new position, use a 3/32" drill bit to carefully drill pilot holes. Ensure the depth is appropriate for the provided screws and does not penetrate the drum's interior.
- Secure the Foot: Insert the provided screws into the foot and through the pilot holes. Using a drill or screwdriver, carefully tighten the screws until the foot is firmly attached to the drum. Do not overtighten, as this may strip the wood or damage the foot.
- Verify Stability: Once installed, gently place the Tubano drum on a flat surface and check for stability. All feet should make even contact with the surface.
Usage and Care
To ensure the longevity and proper function of your Tubano feet and drum:
- Avoid Leaning: Do not lean on the drum or use it as a support.
- Proper Handling: When moving the drum, lift it rather than dragging it by the feet.
- Playing Position: While playing, avoid excessive tilting or putting undue pressure on individual feet.
Maintenance
Regular inspection and minor maintenance can extend the life of your replacement foot:
- Inspect Regularly: Periodically check the foot and screws for any signs of loosening, wear, or damage. Tighten screws if necessary, but do not overtighten.
- Cleaning: If the foot becomes dirty, wipe it clean with a soft, damp cloth. Avoid using abrasive cleaners or harsh chemicals, as these may damage the material.
Troubleshooting
| Problem | Possible Cause | Solution |
|---|---|---|
| Foot does not fit properly. | Incompatible Tubano model. | Ensure your Tubano is a newer model from Remo's 50 or 100 series. This foot is specifically designed for these models. |
| Screws do not secure the foot. | Pilot holes are too large or stripped; screws are not aligned. | Verify pilot hole size (3/32"). If holes are stripped, consider using slightly larger screws (not provided) or repositioning the foot slightly if possible. Ensure screws are aligned before tightening. |
| Drum is unstable after installation. | Foot not installed flush; other feet are damaged. | Re-check installation to ensure the foot is flush. Inspect other feet on the drum for wear or damage and replace if necessary. |
Specifications
- Model: Remo 18-4201-70
- Product Type: Tubano Replacement Foot
- Dimensions: Approximately 4" (length) x 2" (height) x 1" (thickness)
- Material: Metal
- Color: Black
- Compatibility: Recommended for newer models of Remo's 50 or 100 series Tubanos.
- UPC: 757242597170
Warranty and Support
For specific warranty information regarding your Remo 18-4201-70 Tubano Replacement Foot, please refer to the original product documentation or contact Remo customer service directly. Support contact details can typically be found on the official Remo website or product packaging.
Remo Official Website: www.remo.com