Metrex CaviWipes Disinfecting Towelettes Instruction Manual

1. Introduction

Metrex CaviWipes Disinfecting Towelettes are designed for effective cleaning and disinfection of hard, non-porous surfaces in healthcare, laboratory, and clinical environments. These pre-saturated, durable wipes help maintain consistent surface hygiene by providing broad-spectrum disinfection against various microorganisms.

Image 1.1: Metrex CaviWipes Disinfecting Towelettes canister.

2. Product Overview

CaviWipes are non-woven, disposable towelettes pre-saturated with CaviCide, a powerful disinfectant solution. They are formulated to be effective against a wide range of bacteria, viruses, and fungi with a 3-minute kill time.

• Durable Material: Non-woven towelettes resist tearing and bunching, ensuring consistent coverage.
• Pre-Saturated: Ready-to-use directly from the canister, eliminating the need for additional solutions.
• Broad-Spectrum Disinfection: Effective against various bacteria, viruses, and fungi.
• 3-Minute Kill Time: Achieves disinfection in a short contact time.

Image 2.1: Key features of CaviWipes for fast and effective disinfection.

Image 2.2: Design benefits of CaviWipes for efficient cleaning.

3. Setup

1. To start feed, remove the cover and discard the seal.
2. From the center of the towelette roll, pull up a towelette corner.
3. Twist it into a point and thread it through the hole in the container cover.
4. Pull through about one inch.
5. Replace the cover.
6. Pull out the first towelette and tear off at a 90° angle.
7. Remaining towelettes feed automatically, ready for next use.
8. When not in use, keep the center cap closed to prevent solution loss.

Image 3.1: Dispensing a CaviWipe from the canister.

4. Operating Instructions

4.1. General Disinfection of Hard, Non-Porous Surfaces

CaviWipes is a two-step disinfectant product. Always wear appropriate personal protective equipment, such as gloves, when handling.

1. Pre-Cleaning: Use one CaviWipes towelette to completely pre-clean the surface of all visible debris.
2. Disinfection: Use a second CaviWipes towelette to thoroughly wet the surface. Repeated use of the product may be required to ensure that the surface remains visibly wet for 3 minutes at room temperature (68°F/20°C) for tuberculocidal activity and effectiveness against Staphylococcus aureus, Pseudomonas aeruginosa, Trichophyton interdigitale, and Salmonella enterica.
3. For effectiveness against HIV-1, HBV, HCV, and SARS-CoV-2, ensure the surface remains visibly wet for 2 minutes at room temperature (68°F/20°C).

4.2. Disinfection of External Surfaces of Ultrasound Transducers

Pre-clean the ultrasound gel from the external transducer to be disinfected. Then thoroughly wet the probe with a CaviWipes towelette and allow the pre-cleaned surface to remain visibly wet for 3 minutes. Repeated use of the product may be required to ensure that the surface remains visibly wet for 3 minutes at 68°F/20°C.

5. Maintenance

To ensure the longevity and effectiveness of CaviWipes, always keep the center cap of the canister closed tightly when not in use. This prevents the solution from evaporating and keeps the towelettes fresh and fully saturated.

6. Troubleshooting

If you encounter any issues with the product, such as dry wipes or difficulty dispensing, ensure the lid is properly sealed. If the problem persists, contact Metrex customer support for assistance.

7. Specifications

8. Safety Information

CAUTION: Keep out of reach of children. See other panel for additional precautionary statements.

• Personal Protection: Always wear appropriate personal protective equipment, such as disposable protective gloves, protective eyewear, and clothing when handling CaviWipes.
• Do Not Use as a Baby Wipe: This product is not intended for use on skin.
• First Aid: In case of eye contact, flush with water for 15-20 minutes. If irritation persists, seek medical attention. In case of skin contact, wash thoroughly with soap and water. If swallowed, call a poison control center or doctor immediately.

9. Storage and Disposal

9.1. Storage

Store in a cool, dry place away from direct sunlight and heat. Keep the container tightly closed to prevent drying out of the towelettes.

9.2. Disposal

• Towelette Disposal: Do not flush in the toilet. Dispose of used towelettes in accordance with local regulations for infectious materials.
• Container Handling: Non-refillable container. Do not reuse or refill this container. Offer for recycling if available, or dispose of in accordance with local regulations.

10. Warranty and Support

For product support, inquiries, or to report any issues, please contact Metrex customer service. Refer to the product packaging for contact information or visit the official Metrex website.