1. Introduction to This Manual and Your Motorcycle
This manual provides detailed service and repair procedures for the Honda NT700V Deauville and XL700V Transalp motorcycles produced between 2006 and 2013. It is designed for both the professional mechanic and the experienced do-it-yourself enthusiast. Following the instructions carefully will ensure proper maintenance and repair, contributing to the longevity and safe operation of your motorcycle.
Always refer to the safety precautions outlined in this manual before beginning any work. Use appropriate tools and wear personal protective equipment.
2. General Maintenance and Basic Procedures
This section covers fundamental maintenance tasks applicable to both models. Regular checks and basic servicing are crucial for optimal performance and safety.
2.1 Fluid Level Checks
- Engine Oil: Check oil level with the engine warm and the motorcycle on a level surface. Ensure the level is between the upper and lower marks on the dipstick or sight glass.
- Brake Fluid: Verify fluid levels in both front and rear reservoirs. Fluid should be between the MIN and MAX lines. Replace fluid according to the scheduled maintenance.
- Coolant: Inspect the coolant level in the reservoir when the engine is cold. Top up with recommended coolant if necessary.
2.2 Tire Inspection
Regularly check tire pressure, tread depth, and for any signs of damage or wear. Correct tire pressure is vital for handling and tire life.
2.3 Drive System Inspection
For chain-driven models (XL700V), inspect chain slack, lubrication, and wear. For shaft-driven models (NT700V), check for leaks and proper operation.
3. Scheduled Maintenance Intervals
Adhering to the manufacturer's scheduled maintenance is essential for the reliability and longevity of your Honda motorcycle. The following table outlines typical service intervals. Always refer to your specific model's owner's manual for precise details.
| Item | Every 4,000 miles (6,400 km) | Every 8,000 miles (12,800 km) | Every 16,000 miles (25,600 km) |
|---|---|---|---|
| Engine Oil & Filter | Replace | Replace | Replace |
| Spark Plugs | Inspect | Inspect | Replace |
| Air Filter | Inspect | Clean/Replace | Clean/Replace |
| Brake System | Inspect | Inspect | Inspect/Replace Fluid |
| Valve Clearance | - | Inspect | Inspect |
Note: More frequent maintenance may be required for motorcycles operated in severe conditions or at high mileage.
4. Troubleshooting Common Issues
This section provides guidance for diagnosing and resolving common operational problems. Always ensure safety before attempting any diagnostic or repair work.
4.1 Engine Will Not Start
- Check Battery: Ensure battery terminals are clean and tight, and the battery is fully charged.
- Fuel Supply: Verify there is sufficient fuel in the tank and the fuel pump is operating.
- Ignition System: Inspect spark plugs for fouling or damage. Check for spark at the plugs.
- Safety Interlocks: Confirm the engine kill switch is in the "RUN" position and the side stand is up (if applicable).
4.2 Poor Engine Performance
- Air Filter: A clogged air filter can restrict airflow. Inspect and clean/replace as needed.
- Fuel System: Check for clogged fuel injectors or a dirty fuel filter.
- Spark Plugs: Worn or incorrect spark plugs can lead to misfires.
- Valve Clearance: Incorrect valve clearance can affect engine breathing and performance.
5. Technical Specifications
This section provides key technical data for the Honda NT700V Deauville and XL700V Transalp models (2006-2013). Specific values may vary slightly by year and region.
| Category | Specification |
|---|---|
| Engine Type | Liquid-cooled, 4-stroke, 8-valve, SOHC 52° V-twin |
| Displacement | 680 cm³ |
| Bore x Stroke | 81 x 66 mm |
| Compression Ratio | 10.0:1 |
| Fuel System | PGM-FI electronic fuel injection |
| Transmission | 5-speed |
| Final Drive | Shaft (NT700V), Chain (XL700V) |
| Front Suspension | 41mm telescopic fork |
| Rear Suspension | Monoshock with adjustable preload |
| Front Brake | Dual 296mm discs with 3-piston calipers (ABS optional) |
| Rear Brake | Single 276mm disc with 2-piston caliper (ABS optional) |
| Fuel Capacity | Approx. 19.7 liters (NT700V), 17.5 liters (XL700V) |
6. Warranty and Support Information
This manual is a third-party repair guide and does not come with a direct warranty from the publisher for the motorcycle itself. For information regarding your Honda motorcycle's original manufacturer warranty, please refer to the documentation provided with your vehicle at the time of purchase or contact an authorized Honda dealership.
For support related to the content of this repair manual, please contact the publisher directly using the information typically found on the book's copyright page or their official website. This manual is intended as a reference and guide; professional assistance should be sought for complex repairs or if you are unsure about any procedure.
